ZnO/g-C3N4异质结光催化材料的制备及对吡啶的降解

doi:10.19964/j.issn.1006-4990.2023-0527

Abstract

Abstract:

The ZnO/g-C₃N₄ heterojunction photocatalytic materials were prepared by evaporation solvent-high temperature thermal polymerization method.They were systematically characterized by XRD，FTIR，TEM，XPS，UV-vis DRS，PL，TPC and EIS.The activity and stability of ZnO/g-C₃N₄ photocatalytic degradation of pyridine were evaluated.The effects of different factors on the photocatalytic performance were investigated by L₉（3⁴） orthogonal experiment，and the photocatalytic mechanism was discussed.XPS and TEM results proved the formation of heterojunction between ZnO and g-C₃N₄.The formation of heterojunction effectively promoted the separation of photoelectron-holes，improved the light absorption and broadened the spectral range.Under the conditions of ZnO/g-C₃N₄ composite photocatalyst dosage of 50 mg，ZnO/g-C₃N₄ mass ratio of 1∶2，pyridine initial concentration of 20 mg/L and system pH of 7.0，the photocatalytic degradation rate of pyridine by ZnO/g-C₃N₄ reached 98.9% after visible light irradiation for 60 min，and the photocatalytic degradation rate was 97.3% after 5 cycles，which had good stability.The photocatalytic degradation of pyridine by ZnO/g-C₃N₄ was mainly dependent on the action of superoxide radicals（·O₂^-） and holes（h⁺）.

Key words: ZnO/g-C₃N₄, photocatalysis, heterojunction, pyridine

CLC Number:

O643.36

TANG Bei. Preparation of ZnO/g-C₃N₄ heterojunction photocatalytic material and its degradation of pyridine[J]. Inorganic Chemicals Industry, 2024, 56(4): 133-142.

Figures/Tables 13

Fig.1

Fig.2

Fig.3

Fig.4

Fig.5

Fig.6

Table 1

Fig.7

Fig.8

Table 2

Fig.9

Fig.10

Fig.11

References 32

1	李启辉. 煤化工废水处理及资源化利用研究现状［J］. 应用化工， 2023， 52（7）：2234-2238，2243.
	LI Qihui. Research progress on treatment and comprehensive utilization of coal chemical wastewater［J］. Applied Chemical Industry， 2023， 52（7）：2234-2238，2243.
2	马鸣，张新妙，章晨林. 现代煤化工高盐废水处理技术研究进展［J］. 石油化工， 2023， 52（3）：427-432.
	MA Ming， ZHANG Xinmiao， ZHANG Chenlin. Research progress on treatment technologies of high-salinity wastewater from modern coal chemical industry［J］. Petrochemical Technology， 2023， 52（3）：427-432.
3	谢娟，夏润南，赵树春，等. ZnO/煤矸石复合光催化剂的制备与性能研究［J］. 矿产综合利用， 2019（4）：126-129，116.
	XIE Juan， XIA Runnan， ZHAO Shuchun， et al. Preparation and properties of ZnO/coal gangue composite photocatalysts［J］. Multipurpose Utilization of Mineral Resources， 2019（4）：126-129，116.
4	LIAO Quan， RONG Hongwei， ZHAO Meihua， et al. Interaction between tetracycline and microorganisms during wastewater treatment：A review［J］. Science of the Total Environment， 2021， 757：143981. doi: 10.1016/j.scitotenv.2020.143981
5	陈莉荣，宛艳玉，王瑞，等. UV-TiO₂-PS光催化降解煤化工废水中含氮有机物［J］. 化工环保， 2023， 43（3）：313-318. doi: 10.3969/j.issn.1006-1878.2023.03.005
	CHEN Lirong， WAN Yanyu， WANG Rui， et al. Photocatalytic degradation of nitrogen-containing organic compounds in coal chemical wastewater by UV-TiO₂-PS system［J］. Environmental Protection of Chemical Industry， 2023， 43（3）：313-318. doi: 10.3969/j.issn.1006-1878.2023.03.005
6	冯琪淋. 可见光催化-微生物直接耦合技术降解吡啶的机理研究［D］. 南宁：广西大学， 2022.
	FENG Qilin. Study on the mechanism of pyridine degradation by visible light photocatalysis-microorganism direct coupling technology［D］. Nanning： Guangxi university， 2022.
7	JIANG Lei， WEN Yanyi， ZHU Zhongjie， et al. A double cross-linked strategy to construct graphene aerogels with highly efficient methylene blue adsorption performance［J］. Chemosphere， 2021， 265：129169. doi: 10.1016/j.chemosphere.2020.129169
8	PARK B H， KIM S， SEO A Y， et al. Evaluation of optimal conditions for anionic surfactant removal in wastewater［J］. Chemosphere， 2021， 263：128174. doi: 10.1016/j.chemosphere.2020.128174
9	麻微微，施雪卿，孔巧平，等. 微电解耦合同步硝化反硝化工艺强化煤化工废水脱氮效能及微生物群落结构研究［J］. 环境科学学报， 2022， 42（3）：130-140.
	MA Weiwei， SHI Xueqing， KONG Qiaoping， et al. Nitrogen removal efficiency and microbial community characteristics in microelectrolysis coupled simultaneous nitrification and denitrification process for coal chemical wastewater treatment［J］. Acta Scientiae Circumstantiae， 2022， 42（3）：130-140.
10	张文，林长喜，彭永臻. 现代煤化工废水近零排放技术集成与优化建议［J］. 环境工程， 2021， 39（11）：41-45，109.
	ZHANG Wen， LIN Changxi， PENG Yongzhen. Recommendations on integration and optimization of near-zero discharge technology for wastewater from modern coal chemical industry［J］. Environmental Engineering， 2021， 39（11）：41-45，109.
11	解彬，宋泽宇，雷珂，等. 关于实现煤化工废水零排放工艺设计的研究［J］. 应用化工， 2021， 50（9）：2534-2539.
	XIE Bin， SONG Zeyu， LEI Ke， et al. Research on process design of zero discharge of coal chemical wastewater［J］. Applied Chemical Industry， 2021， 50（9）：2534-2539.
12	孙海杰，刘欣改，陈志浩，等. BiOI/g-C₃N₄光催化降解甲基橙研究［J］. 无机盐工业， 2021， 53（4）：90-94.
	SUN Haijie， LIU Xin′gai， CHEN Zhihao， et al. Study on photocatalytic degradation of methyl orange by BiOI/g-C₃N₄ ［J］. Inorganic Chemicals Industry， 2021， 53（4）：90-94.
13	QU Zhengjun， JING Zhenyang， CHEN Xiaoming， et al. Preparation and photocatalytic performance study of dual Z-scheme Bi₂Zr₂O₇/g-C₃N₄/Ag₃PO₄ for removal of antibiotics by visible-light［J］. Journal of Environmental Sciences， 2023， 125：349-361. doi: 10.1016/j.jes.2022.01.010 pmid: 36375920
14	LIU Yuanyuan， TIAN Jing， WEI Linyu， et al. Modified g-C₃N₄/TiO₂/CdS ternary heterojunction nanocomposite as highly visible light active photocatalyst originated from CdS as the electron source of TiO₂ to accelerate Z-type heterojunction［J］. Separation and Purification Technology， 2021， 257：117976. doi: 10.1016/j.seppur.2020.117976
15	WANG Xunhe， HE Meilin， Zhaodong NAN. Effects of adsorption capacity and activity site on Fenton-like catalytic performance for Na and Fe co-doped g-C₃N₄ ［J］. Separation and Purification Technology， 2021， 256：117765. doi: 10.1016/j.seppur.2020.117765
16	董伟，常启明，王文博，等. g-C₃N₄纳米片的剥离制备方法研究进展［J］. 硅酸盐学报， 2023， 51（7）：1868-1882.
	DONG Wei， CHANG Qiming， WANG Wenbo， et al. Research progress in preparing methods of g-C₃N₄ nanosheets by exfoliation［J］. Journal of the Chinese Ceramic Society， 2023， 51（7）：1868-1882.
17	陈彰旭，朱丹琛，傅明连. g-C₃N₄/TiO₂复合材料制备及其处理罗丹明B研究［J］. 无机盐工业， 2023， 55（7）：130-136.
	CHEN Zhangxu， ZHU Danchen， FU Minglian. Study on preparation of g-C₃N₄/TiO₂ composites and application for rhodamine B removal［J］. Inorganic Chemicals Industry， 2023， 55（7）：130- 136.
18	陈建军，周诗园，黄雨晨，等. 无定型碳/g-C₃N₄制备及其光催化降解四环素性能［J］. 化学试剂， 2023， 45（7）：107-112.
	CHEN Jianjun， ZHOU Shiyuan， HUANG Yuchen， et al. Preparation of amorphous carbon/g-C₃N₄ and its photocatalytic degradation of tetracycline［J］. Chemical Reagents， 2023， 45（7）：107- 112.
19	汲畅，王国胜. Ag₃PO₄/g-C₃N₄异质结催化剂可见光降解黄连素［J］. 无机盐工业， 2022， 54（4）：175-180.
	JI Chang， WANG Guosheng. Degradation of berberine by visible light over Ag₃PO₄/g-C₃N₄ heterojunction catalyst［J］. Inorganic Chemicals Industry， 2022， 54（4）：175-180.
20	卜义夫，刘思乐，杜文娟，等. 二硫化钼/石墨相氮化碳光催
	化降解印染废水研究［J］. 皮革科学与工程， 2023， 33（3）：12- 18.
	BU Yifu， LIU Sile， DU Wenjuan， et al. Study on photocatalytic degradation of printing and dyeing wastewater by molybdenum disulfide/graphite carbon nitride［J］. Leather Science and Engineering， 2023， 33（3）：12-18.
21	黄曦瑶，李明春，郭银彤. g-C₃N₄/Bi/Bi₂WO₆光催化材料的协同改性研究［J］. 无机盐工业， 2022， 54（12）：133-138.
	HUANG Xiyao， LI Mingchun， GUO Yintong. Study on synergistic modification of g-C₃N₄/Bi/Bi₂WO₆ photocatalyst［J］. Inorganic Chemicals Industry， 2022， 54（12）：133-138.
22	曾楠，柴希娟，胡玲华，等. ZnO复合石墨相氮化碳纳米片的制备及其光催化性能研究［J］. 材料科学与工艺， 2023， 31（4）：41-50.
	ZENG Nan， CHAI Xijuan， HU Linghua， et al. Preparation and photocatalytic properties of ZnO composite graphitic carbon nitride nanosheets［J］. Materials Science and Technology， 2023， 31（4）：41-50.
23	谢锋，郭建峰，王海涛，等. ZnO/CdS/Ag复合光催化剂的制备及其催化和抗菌性能［J］. 材料研究学报， 2023， 37（1）：10-20. doi: 10.11901/1005.3093.2021.586
	XIE Feng， GUO Jianfeng， WANG Haitao， et al. Construction of ZnO/CdS/Ag composite photocatalyst and its catalytic and antibacterial performance［J］. Chinese Journal of Materials Research， 2023， 37（1）：10-20. doi: 10.11901/1005.3093.2021.586
24	XU Peng， WANG Peng， WANG Qiao， et al. Facile synthesis of Ag₂O/ZnO/rGO heterojunction with enhanced photocatalytic activity under simulated solar light：Kinetics and mechanism［J］. Journal of Hazardous Materials， 2021， 403：124011. doi: 10.1016/j.jhazmat.2020.124011
25	SILVA F F DA， SILVA R B DA， SILVA T R， et al. Boosting the photocatalytic activity of g-C₃N₄/ZnO heterojunctions through optimal control of mass ratio［J］. Solid State Sciences， 2023， 138：107128. doi: 10.1016/j.solidstatesciences.2023.107128
26	TAN Xu， WANG Xing， HANG He， et al. Self-assembly method assisted synthesis of g-C₃N₄/ZnO heterostructure nanocomposites with enhanced photocatalytic performance［J］. Optical Materials， 2019， 96：109266. doi: 10.1016/j.optmat.2019.109266
27	VINOTH S， SUBRAMANI K， ONG W J， et al. CoS₂ engulfed ultra-thin S-doped g-C₃N₄ and its enhanced electrochemical performance in hybrid asymmetric supercapacitor［J］. Journal of Colloid and Interface Science， 2021， 584：204-215. doi: 10.1016/j.jcis.2020.09.071
28	LIU Dong， YAO Jia， CHEN Shentao， et al. Construction of rGO-coupled C₃N₄/C₃N₅ 2D/2D Z-scheme heterojunction to accelerate charge separation for efficient visible light H₂ evolution［J］. Applied Catalysis B：Environmental， 2022， 318：121822.
29	SUN Qi， SUN Ying， ZHOU Miya， et al. A 2D/3D g-C₃N₄/ZnO heterojunction enhanced visible-light driven photocatalytic activity for sulfonamides degradation［J］. Ceramics International， 2022， 48（5）：7283-7290. doi: 10.1016/j.ceramint.2021.11.289
30	ZHANG Zhengyi， SUN Yangshan， WANG Youle， et al. Synthesis and photocatalytic activity of g-C₃N₄/ZnO composite microspheres under visible light exposure［J］. Ceramics International， 2022， 48（3）：3293-3302. doi: 10.1016/j.ceramint.2021.10.104
31	WANG Libo， CHENG Bei， ZHANG Liuyang， et al. In situ irradiated XPS investigation on S-scheme TiO₂@ZnIn₂S₄ photocatalyst for efficient photocatalytic CO₂ reduction［J］. Small， 2021， 17（41）： e2103447.
32	VAHABIRAD S， NEZAMZADEH-EJHIEH A. Co-precipitation synthesis of BiOI/（BiO）₂CO₃：Brief characterization and the kinetic study in the photodegradation and mineralization of sulfas-alazine［J］. Journal of Solid State Chemistry， 2022， 310：123018. doi: 10.1016/j.jssc.2022.123018

次数	因素				吡啶降解率/%
次数	催化剂投加量/mg	m（ZnO）∶ m（g-C₃N₄）	吡啶初始质量浓度/（mg·L^-1）	体系 pH	吡啶降解率/%
1	40	1∶2	10	6.0	92.3
2	40	1∶1	20	7.0	92.1
3	40	1∶3	30	8.0	89.8
4	50	1∶2	20	8.0	96.2
5	50	1∶1	30	6.0	89.6
6	50	1∶3	10	7.0	90.5
7	60	1∶2	30	7.0	91.3
8	60	1∶1	10	8.0	86.7
9	60	1∶3	20	6.0	89.5
验证	50	1∶2	20	7.0	98.9
均值1	91.400	93.267	89.833	90.467
均值2	92.100	89.467	92.600	91.300
均值3	89.167	89.933	90.233	90.900
极差	2.933	3.800	2.767	0.833

循环次数	吡啶降解率/%	循环次数	吡啶降解率/%
1	98.9	4	97.8
2	98.5	5	97.3
3	98.1

[1]	SHI Wangfang, ZHANG Yongsheng. Study on NO _x degradation performance of concrete-based non-metallic boron doped nitrogen-rich carbon nitride [J]. Inorganic Chemicals Industry, 2025, 57(3): 116-123.
[2]	LI Zihan, ZHANG Jiaqi, LI Shizhuo, LI Xinyu, LIU Shaozhuo, WANG Yihao, HAO Yucui, LIU Jian, LI Yanhua. Study on synthesis and catalytic mechanism of CdS/g-C₃N₄composite photocatalyst [J]. Inorganic Chemicals Industry, 2025, 57(3): 124-132.
[3]	SUN Qinghao, LI Keyan, GUO Xinwen. Study on photocatalytic benzyl alcohol oxidation coupled with hydrogen production over Pd/ZnIn₂S₄ nanosheets [J]. Inorganic Chemicals Industry, 2025, 57(1): 113-119.
[4]	LIU Guangming. Study on photocatalytic and mechanical properties of C₃N₅/NH₂-MIL-125（Ti） modified concrete mortar [J]. Inorganic Chemicals Industry, 2025, 57(1): 120-128.
[5]	ZHANG Feigang, LIU Zhongli. Study on application of CuO/g-C₃N₄ composites in organic dye degradation and supercapacitors [J]. Inorganic Chemicals Industry, 2025, 57(1): 129-136.
[6]	ZHANG Guoqiang, RONG Xilin, XIAO Zhenfang, XUE Ziran, CHENG Hao, FENG Jun, LIU Quan, LU Yao, HUANG Wenyi. Study on preparation and photocatalytic properties of bagasse carbon aerogels loaded with zinc oxide nanoparticles [J]. Inorganic Chemicals Industry, 2024, 56(8): 131-138.
[7]	WANG Yawen, WANG Fangfang, GENG Siyu, JU Jia, CHEN Lei, CHEN Changdong. Study on preparation and photocatalytic performance of SrTiO₃-SrWO₄ [J]. Inorganic Chemicals Industry, 2024, 56(7): 143-149.
[8]	LIU Min, HUANG Xiu, ZHANG Liyuan. Research progress of S-type heterojunction photocatalysts [J]. Inorganic Chemicals Industry, 2024, 56(7): 18-27.
[9]	LI Jiangpeng, ZHANG Huibin. Synergistic degradation of methylene blue by photo-Fenton and photocatalytic with 3D porous LaFeO₃/CeO₂/SrTiO₃ [J]. Inorganic Chemicals Industry, 2024, 56(5): 141-148.
[10]	HUANG Jianan, LU Xiaoyu, WANG Mitang. Effect of Ba-La co-doping on degradation of methylene blue dye by TaON [J]. Inorganic Chemicals Industry, 2024, 56(2): 146-151.
[11]	ZUO Guangling, WANG Minghui, PENG Yunying, DU Jia, YE Hongyong. Study on hnoneycomb-like LaVO₄/Bi₂O₃ heterojunction for photocatalytic degradation of tetracycline hydrochloride [J]. Inorganic Chemicals Industry, 2024, 56(11): 158-164.
[12]	CUI Xiangdong, LIU Sile. Study on photoelectric performance analysis of g-C₃N₅ nanorods and removal of Cr（Ⅵ） and methylene blue [J]. Inorganic Chemicals Industry, 2024, 56(10): 159-168.
[13]	YAN Yu, ZHOU Wenyuan, YANG Yunfei, WU Junshu, WANG Jinshu, SUN Lingmin. Study on surface regulation of sodium ferric silicate photocatalyst and its enhanced Cr（Ⅵ） photoreduction properties [J]. Inorganic Chemicals Industry, 2024, 56(10): 141-150.
[14]	MA Yihong, CHEN Xingtao, TANG Lei. Treatment of printing wastewater by chemical coagulation-TiO₂/g-C₃N₅ photocatalytic degradation [J]. Inorganic Chemicals Industry, 2024, 56(10): 151-158.
[15]	YANG Bo, LIANG Zhiyan, LIU Wenyuan, CAO Jiazhen, LIU Xinyue, XING Mingyang. Research progress of application of molybdenum-based catalytic materials for water pollution control [J]. Inorganic Chemicals Industry, 2023, 55(8): 1-12.

National Inorganic Salts Information Center

Inorganic Acid-Base-Salt Committee of CIESC

Preparation of ZnO/g-C₃N₄ heterojunction photocatalytic material and its degradation of pyridine

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 13

References 32

Related Articles 15

Metrics

Comments

Recommended 0

Preparation of ZnO/g-C3N4 heterojunction photocatalytic material and its degradation of pyridine