一氧化碳脱毒铬渣制备水泥矿物掺合料

doi:10.11962/1006-4990.2020-0366

无机盐工业 ›› 2021, Vol. 53 ›› Issue (5): 73-77.doi: 10.11962/1006-4990.2020-0366

一氧化碳脱毒铬渣制备水泥矿物掺合料

何力为^1,²,周学进^2,³,宁平²()

1.昆明学院,滇池（湖泊）污染防治合作研究中心,云南昆明 650214
2.昆明理工大学环境科学与工程学院
3.云南云投生态环境科技股份有限公司

收稿日期:2020-08-13 出版日期:2021-05-10 发布日期:2021-05-12
通讯作者: 宁平
作者简介:范天博（1976— ）,男,博士,副教授,主要研究方向为无机化学工程;E-mail address： eftb@163.com。|何力为（1987— ）,女,博士,讲师,研究方向为污染控制工程、固废治理及资源化。
基金资助:
国家自然基金(61102041);辽宁省高校创新团队支撑计划(2013010);国家科技支撑计划(2013BAB09B01);辽宁省教育厅项目(L2013169);辽宁省精细化工协同创新中心资助项目;辽宁省自然基金(201602582);辽宁省自然科学基金指导计划项目：基于涡致振动的宽带压电能量收集结构研究(2019-ZD-0075);国家重点研发计划(2017YFC0210504);西部典型产业环境污染控制协同创新中心开放基金(XTCX-2014-01)

Preparation of cement mineral admixture from chromium slag detoxified by carbon monoxide

He Liwei^1,²,Zhou Xuejin^2,³,Ning Ping²()

1. Kunming Dianchi Lake Environmental Protection Collaborative Research Center,Kunming University,Kunming 650214,China
2. School of Environmental Science and Engineering,Kunming University of Science and Technology
3. Yunnan Yuntou Ecology and Environmental Technology Co.,Ltd.

Received:2020-08-13 Online:2021-05-10 Published:2021-05-12
Contact: Ning Ping

摘要/Abstract

摘要：

实验研究了模拟一氧化碳工业废气解毒的脱毒铬渣制备水泥矿物掺合料时,其添加比对胶砂试件抗压、抗折强度及凝结时间的影响,测定了试件中总铬（Cr）和六价铬Cr（Ⅵ）浸出浓度,并采用半动态浸出实验测定其有效扩散系数D和扩散因子L。结果表明,细磨后的脱毒铬渣符合水泥矿物掺合料的性能要求,随着添加比例的增加,胶砂凝结时间增加,抗压、抗折强度下降,但各实验组试件均达到C60的强度等级要求。试件中Cr（Ⅵ）和总Cr的D值达到10^-10~10^-9数量级,L值>9,迁移能力极低,证明制备矿物掺合料是一种安全有效的脱毒铬渣资源化处置方法。

关键词: 白云石, 缓冲体系, 球霰石, 碳酸钙, 脱毒铬渣, 矿物掺合料, 一氧化碳, 水泥

Abstract:

The influence of the addition ratio of chromium slag detoxified by carbon monoxide off-gas on the compressive strength,bending strength and setting time of concrete test samples were experimentally studied.The leaching concentrations of total chromium（Cr） and hexavalent chromium Cr（Ⅵ）were determined,and their effective diffusion co-efficient D and diffu-sion factor L were calculated by semi-dynamic leaching experiment.The results showed that the detoxified chromium slag after fine grinding could meet the requirement of cement mineral admixture.With the increase of adding ratio,the setting time of mortar were extended,the compressive and bending strength were declined,but all the experimental groups meet the strength grade requirements of C60.The D value of Cr（Ⅵ） and total Cr in the sample was 10^-10~10^-9,L value was more than 9,and the migration ability was very low,which proved that the preparation of mineral admixtures was a safe and effective resource disposal method for detoxified chromium slag.

Key words: dolomite, buffer system, vaterite, calcium carbonate, detoxified chromium residue, mineral admixture, carbon monoxide, cement

中图分类号:

何力为,周学进,宁平. 一氧化碳脱毒铬渣制备水泥矿物掺合料[J]. 无机盐工业, 2021, 53(5): 73-77.

He Liwei,Zhou Xuejin,Ning Ping. Preparation of cement mineral admixture from chromium slag detoxified by carbon monoxide[J]. Inorganic Chemicals Industry, 2021, 53(5): 73-77.

图/表 15

图1

表1

表2

图2

图3

表3

图1

图4

图5

图2

表4

图6

图7

图8

图9

参考文献 26

[6]	Fu Lianhua, Qi Chao, Hu Yanru, et al. Cellulose/vaterite nanocom-posites:Sonochemical synjournal,characterization,and their appli-cation in protein adsorption[J]. Materials Science & Engineering C, 2019,96:426-435.
[7]	Wang Xiaoqiang, Wu Congmeng, Tao Kai, et al. Influence of oval-bumin on CaCO₃ precipitation during in vitro biomineralization[J]. Journal of Physical Chemistry B, 2010,114(16):5301. doi: 10.1021/jp1008237 pmid: 20369864
[8]	Liu Y, Cui Y J, Mao H Y, et al. Calcium carbonate crystallization in the presence of casein[J]. Crystal Growth & Design, 2012,12(10):4720-4726. doi: 10.1021/cg3005213
[9]	Porter A L, Wilson W J. Manufacture of precipitated calcium carbona-te of improved color and stable crystalline form：US,6132696A[P]. 2000-10-17.
[10]	黄文艺, 马蓝宇, 程昊, 等. 氯化铝对碳酸钙结晶形貌的影响[J]. 无机盐工业, 2018,50(1):20-23.
[1]	纪柱. 中国铬盐近五十年发展概况[J]. 无机盐工业, 2010,42(12):1-15.
[11]	Di Profio Gianluca, Salehi Shabnam Majidi, Caliandro Rocco, et al. Bioinspired synjournal of CaCO₃ superstructures through a novel hy-drogel composite membranes mineralization platform:A comprehe-nsive view[J]. Advanced Materials, 2016,28(4):610-616. doi: 10.1002/adma.201504608
[2]	Walawska B, Kowalski Z. Model of technological alternatives of pro-duction of sodium chromate(Ⅵ) with the use of chromic wastes[J]. Waste Management, 2000,20(8):711-723. doi: 10.1016/S0956-053X(00)00038-6
[3]	Hori M, Shozugawa K, Matsuo M. Hexavalent chromium pollution caused by dumped chromium slag at the urban park in Tokyo[J]. Journal of Material Cycles & Waste Management, 2015,17(1):201-205.
[12]	郑天文, 陈雪梅. 球霰石碳酸钙微球的合成及其机理[J]. 材料科学与工程学报, 2018(3):358-364
[13]	Loïc Dupont, François Portemer, the late Michel Figlarz. Synjournal and study of a well crystallized CaCO₃ vaterite showing a new habi-tus[J]. Journal of Materials Chemistry, 1997,7(5):797-800. doi: 10.1039/a607761g
[4]	Matern K, Weigand H, Singh A, et al. Environmental status of gro-undwater affected by chromite ore processing residue(COPR) dum-psites during pre-monsoon and monsoon seasons[J]. Environmental Science & Pollution Research, 2017,24(4):3582-3592.
[14]	Dmitry V V, Alexander I P, Michelle P, et al. Matrix polyelectrolyte microcapsules:New system for macromoleculeen-capsulation[J]. Langmuir, 2004,20(8):3398-3406. doi: 10.1021/la036177z
[5]	刘帅霞. 两段式还原工艺解毒铬渣技术研究[D]. 上海:东华大学, 2013.
[6]	Li Y, Cundy A B, Feng J, et al. Remediation of hexavalent chromium contamination in chromite ore processing residue by sodium dithio-nite and sodium phosphate addition and its mechanism[J]. Journal of Environmental Management, 2017,192(5):100-106. doi: 10.1016/j.jenvman.2017.01.031
[15]	陈佩圆, 胡秀平, 孙龙, 等. 快速沉淀法制备高分散高纯度球霰石晶体[J]. 人工晶体学报, 2019,48(3):114-118.
[7]	Panneerselvam P, Choppala G, Kunhikrishnan A, et al. Potential of novel bacterial consortium for the remediation of chromium contam-ination[J]. Water,Air,and Soil Pollution, 2013,224(12):211-221.
[16]	Ramesh T N, Inchara S A, Pallavi K. Para-amino benzoic acid-me-diated synjournal of vaterite phase of calcium carbonate[J]. Journal of Chemical Sciences, 2015,127(5):843-848. doi: 10.1007/s12039-015-0849-3
[17]	邹俭鹏, 杨洪志, 肖平, 等. 微纳分级结构碳酸钙中空微球的可控制备[J]. 无机材料学报, 2016,31(7):711-718.
[8]	Chen J, Wang Y, Zhou S, et al. Reduction/immobilization processes of hexavalent chromium using metakaolin-based geopolymer[J]. Jour-nal of Environmental Chemical Engineering, 2016,4(2):2084-2089.
[9]	何力为, 李彬, 宁平, 等. 利用一氧化碳工业废气解毒铬渣的方法及条件优化[J]. 环境工程学报, 2018,12(9):195-204.
[18]	Hu Qiaona, Zhang Jiaming, Henry Teng, et al. Growth process and crystallographic properties of ammonia-induced vaterite[J]. Ame-rican Mineralogist, 2015,97(8/9):1437-1445.
[10]	Bagheri A, Nazari A. Compressive strength of high strength class C fly ash-based geopolymers with reactive granulated blast furnace slag aggregates designed by Taguchi method[J]. Materials & De-sign, 2014,54(2):483-490.
[11]	He L, Li B, Ning P, et al. Chromium slag detoxification by carbon monoxide off-gases and optimization of detoxification parameters by Box-Behnken design[J]. Journal of Material Cycles and Waste Management, 2019,22(3):111-122. doi: 10.1007/s10163-019-00918-1
[12]	白智韬, 邱桂博, 彭犇, 等. 高碳铬铁渣基微晶玻璃体系调控分析[J]. 环境工程, 2019,37(1):158-163.
[13]	方久华, 杨峰, 左明扬, 等. 玻璃配合料中铬渣最大允许用量研究[J]. 无机盐工业, 2015,47(1):18-21.
[14]	冯勇, 韩艳丽. 钢渣混凝土抗硫酸盐、镁盐侵蚀性能的实验分析[J]. 硅酸盐通报, 2015,34(11):3345-3351.
[15]	Jagupilla S C, Moon D H, Wazne M, et al. Effects of particle size and acid addition on the remediation of chromite ore processing re-sidue using ferrous sulfate[J]. Journal of Hazardous Materials, 2009,168(1):121-128. doi: 10.1016/j.jhazmat.2009.02.012 pmid: 19272700
[16]	Chrysochoou M, Fakra S C, Marcus M A, et al. Microstructural an-alyses of Cr(Ⅵ) speciation in chromite ore processing residue (COPR)[J]. Environmental Science & Technology, 2009,43(14):5461-5466. doi: 10.1021/es9005338
[17]	GB/T 17671—1999 水泥胶砂强度实验[S].
[18]	GB/T 7023—2011 低、中水平放射性废物固化体标准浸出实验方法[S].
[19]	HJ/T 299—2007 固体废物浸出毒性浸出方法硫酸硝酸法[S].
[20]	GB/T 15555.4—1995 固体废物六价铬的测定二苯碳酰二肼分光光度法[S].
[21]	HJ 687—2014 固体废物六价铬的测定碱消解/火焰原子吸收分光光度法[S].
[22]	HJ/T 301—2007 铬渣污染治理环境保护技术规范(暂行)[S].
[23]	GB/T 203—2008 用于水泥中的粒化高炉矿渣[S].
[24]	GB/T 2847—2005 用于水泥中的火山灰质混合材料[S].
[25]	GB 175—2007 通用硅酸盐水泥[S].
[26]	Dutre V, Vandecasteele C. An evaluation of the solidification/stabi-lization of industrial arsenic containing waste using extraction and semi-dynamic leach tests[J]. Waste Management, 1996,16(7):625-631. doi: 10.1016/S0956-053X(97)00003-2

编号	m（水泥）/g	m（铬渣）/g	m（标准砂）/g	说明
0	450	0	1 350	对照
A-1	405	45	1 350	10%
A-2	360	90	1 350	20%
A-3	315	135	1 350	30%
A-4	270	180	1 350	0%

编号	初凝时间	终凝时间	编号	初凝时间	终凝时间
0	217	252	A-3	227	294
A-1	218	275	A-4	230	295
A-2	221	289

编号	Cr（Ⅵ）平均有效扩散系数D/（cm²·s^-1）	Cr（Ⅵ）浸出因子L	编号	总Cr平均有效扩散系数 D/（cm²·s^-1）	总Cr 浸出因子L
A-1	3.57×10^-10	9.63	A-1	1.56×10^-10	10.27
A-2	4.63×10^-10	9.53	A-2	3.58×10^-10	9.61
A-3	7.43×10^-10	9.36	A-3	2.89×10^-10	9.74
A-4	1.48×10^-9	9.11	A-4	2.14×10^-10	9.84

首页

全国无机盐信息中心

中国化工学会

无机酸碱盐专业委员会

一氧化碳脱毒铬渣制备水泥矿物掺合料

Preparation of cement mineral admixture from chromium slag detoxified by carbon monoxide

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 15

参考文献 26

相关文章 15

Metrics

本文评价

推荐阅读 10

[1]	胡彩霞,胡辰鑫,彭剑龙,钟星. 以可溶性淀粉为晶型调控剂制备多孔球形碳酸钙[J]. 无机盐工业, 2021, 53(5): 51-55.
[2]	范天博,贾晓辉,韩冬雪,陈思,姜宇,胡婷婷,郭洪范,李莉,刘云义. 以白云石为原料氨碱法制备球霰石及其生成机理研究[J]. 无机盐工业, 2021, 53(5): 56-60.
[3]	叶为辉,吕琪,龙长江. 高密度类球形碱式碳酸镍快速制备工艺研究[J]. 无机盐工业, 2021, 53(5): 69-72.
[4]	赵历,卓民权,龚福忠,王俊,阮恒,李开成,李艳琳. 碳化法制备球霰石碳酸钙微球及形成机理[J]. 无机盐工业, 2021, 53(3): 38-43.
[5]	颜鑫,吴健谊,卢云峰,颜子腾. 氨碱厂碱渣充分综合利用新技术的研究[J]. 无机盐工业, 2021, 53(1): 68-71.
[6]	张彬,肖霄,韩芸娇,张媛媛,于宏伟. 碳酸钙三级红外光谱研究[J]. 无机盐工业, 2021, 53(1): 97-101.
[7]	张晨霞. 新型磷酸镁水泥固化挥发型重金属锌的研究[J]. 无机盐工业, 2020, 52(5): 71-74.
[8]	颜鑫. 彩色纳米碳酸钙的研制[J]. 无机盐工业, 2020, 52(5): 53-55.
[9]	苏少龙,曲晓龙,钟读乐,孙彦民,马月谦. 工业氢氧化钙中氧化钙、氢氧化钙及碳酸钙测定方法的研究[J]. 无机盐工业, 2020, 52(5): 75-77.
[10]	景亭. 改性纳米碳酸钙用于硅酮胶挤出性研究[J]. 无机盐工业, 2020, 52(4): 57-60.
[11]	何青峰,曾利群,何朝晖,刘晓菲,邹佳骏. 除氯处理的PAC废渣的细度和掺量对水泥性能影响的研究[J]. 无机盐工业, 2020, 52(4): 84-87.
[12]	王倩倩,白春华,任慧,李光辉. 碳酸钙晶型的肉豆蔻酸调控研究[J]. 无机盐工业, 2020, 52(4): 29-32.
[13]	王宇斌,王望泊,朱新锋,荀婧雯,党炜犇. 磁化条件下不同镁盐对碳酸钙溶解行为的影响[J]. 无机盐工业, 2020, 52(3): 35-38.
[14]	张文仙,刘联胜,曹和军,吴槟克,程振鹏. 二氧化碳浓度对石灰石分解反应动力学的影响[J]. 无机盐工业, 2020, 52(3): 59-63.
[15]	王刚,唐盛伟,陈彦逍,张涛. 二水硫酸钙间接矿化二氧化碳CTAB对碳酸钙晶型的影响[J]. 无机盐工业, 2020, 52(3): 75-79.

首 页

一氧化碳脱毒铬渣制备水泥矿物掺合料

Preparation of cement mineral admixture from chromium slag detoxified by carbon monoxide

RichHTML

PDF (PC)

可视化

引用本文

使用本文

首页