介孔Cu/MS-1催化羟基化苯酚合成苯二酚

doi:10.11962/1006-4990.2020-0110

Abstract

Abstract:

The mesoporous S-1（MS-1） supporter was synthesized by sol-gel method with cetyltrimethyl-ammonium bromide（CTAB） as template.Cu/MS-1 catalyst was prepared by impregnation method,and then it was used to synthesis dihydroxy-benzenes directly by hydroxylation phenol with H₂O₂ as oxidation.The experimental conditions were optimized by orthogonal experimental[L₂₅（5⁶）].The structure and properties of catalyst were characterized by means of X-ray photoelectron spectro-scopy（XPS）,N₂ adsorption-desorption and H₂ temperature programmed reduction et al.The results showed that Cu/ MS-1 with mesoporous promised to rapid diffusion in pore of reactants and products,and was better catalytic performance than that of Cu/S-1.Under optimal conditions,the 5.5% Cu/MS-1 with the highest relative mass fraction of highly dispersed CuO pos-sessed the best catalytic activity among the catalysts; the yield of dihydroxybenzenes was 47.2% with the selectivity of 86.7%.The catalysts with mesoporous and MFI structure had a good sustainability,and its dihydroxybenzenes yield was 43.2% after recycle 5 times.

Key words: dihydroxybenzenes, CTAB, catalyst, phenol, hydrogen peroxide

CLC Number:

TQ131.21

Yu Tianhua,Huang Qipeng,Situ Cheng. Synthesis of dihydroxybenzenes by hydroxylation of phenol over Cu/ MS-1 with mesoporous[J]. Inorganic Chemicals Industry, 2021, 53(2): 94-99.

Figures/Tables 10

References 26

[1]	Kuzniarska-Biernacka I, Raposo M M M, Batista R M F, et al. Binu-clear furanyl-azine metal complexes encapsulated in NaY zeolite as efficiently heterogeneous catalysts for phenol hydroxylation[J]. Journal of Molecular Structure, 2020,1206:127687-127697. doi: 10.1016/j.molstruc.2020.127687
[2]	Li B, Wu W B, Zhang T Y, et al. Ferrocene particles incorporated into Zr-based metal-organic frameworks for selective phenol hydro-xylation to dihydroxybenzenes[J].RSC Advances,2017(7):38691-38698.
[3]	Liu M X, Wang H, Zhu P Q, et al. Tuning the oxidation state of co-pper in CuMgAl hydrotalcite using partially oxidized MoS₂ for effi-cient hydroxylation of phenol[J]. Catalysis Communications, 2019,129:105752-105754. doi: 10.1016/j.catcom.2019.105752
[4]	Ivanov D P, Pirutko L V, Panov G I. Effect of steaming on the cataly-tic performance of ZSM-5 zeolite in the selective oxidation of phe-nol by nitrous oxide[J]. Journal of Catalysis, 2014,311:424-432. doi: 10.1016/j.jcat.2013.12.010
[5]	Ivanov D P, Sobolev V I, Pirutko L V, et al. New way of hydroqui-none and catechol synjournal using nitrous oxide as oxidant[J]. Adv-anced Synjournal & Catalysis, 2002,344:986-995.
[6]	Hai L, Zhang T Y, Zhang X, et al, Catalytic hydroxylation of phenol to dihydroxybenzene by Fe(Ⅱ) complex in aqueous phase at am-bient temperature[J]. Catalysis Communications, 2017,101:93-97. doi: 10.1016/j.catcom.2017.08.001
[7]	Tahara S, Nagai S, Hayashi Y, et al. Method for preparing catechol and hydroquinone：US,3920756[P],1975-11-18.
[8]	邵艳秋, 张宇婷, 姜振双, 等. 水解剂氟化铵对Fe-SBA-15结构及催化性能的影响[J]. 无机盐工业, 2019,51(9):97-101.
[9]	Wu G Q, Xiao J H, Zhang L, et al. Copper-modified TS-1 catalyzed hydroxylation of phenol with hydrogen peroxide as the oxidant[J]. RSC Advances, 2016,6:101071-101078. doi: 10.1039/C6RA20980G
[10]	Karakhanov E A, Maximov A L, Kardasheva Y S, et al, Copper nanoparticles as active catalysts in hydroxylation of phenol by hydrogen peroxide[J]. Applied Catalysis A:General, 2010,385:62-72. doi: 10.1016/j.apcata.2010.06.042
[11]	Xiao F S, Sun J M, Meng X J, et al. Synjournal and structure of co-pper hydroxyphosphate and its high catalytic activity in hydroxyla-tion of phenol by H₂O₂[J]. Journal of Catalysis, 2001,199:273-281. doi: 10.1006/jcat.2001.3166
[12]	Noreña-Franco L, Hernandez-Perez I, Aguilar-Pliego J, et al. Se-lective hydroxylation of phenol employing Cu-MCM-41 catalys-ts[J]. Catalysis Today, 2002,75:189-195. doi: 10.1016/S0920-5861(02)00067-6
[13]	Zhang H L, Tang C J, Lv Y Y, et al. Synjournal,characterization,and catalytic performance of copper-containing SBA-15 in the phenol hydroxylation[J]. Journal of Colloid and Interface Science, 2012,380:16-24. doi: 10.1016/j.jcis.2012.04.059
[14]	Tang H L, Ren Y, Yue B, et al. Cu-incorporated mesoporous ma-terials:Synjournal,characterization and catalytic activity in phenol hydroxylation[J]. Journal of Molecular Catalysis A:Chemical, 2006,260:121-127. doi: 10.1016/j.molcata.2006.07.019
[15]	余天华, 敖厚豫, 黄启鹏, 等. 多级孔钛硅分子筛制备及催化羟基化性能[J]. 无机盐工业, 2019,51(9):102-105.
[16]	Flanigen E M, Bennett J M, Grose R W, et al. Silicalite,a new hy-drophobic crystalline silica molecular sieve[J]. Nature, 1978,271:512-516. doi: 10.1038/271512a0
[17]	任宣籼, 宋万仓, 邱宇, 等. 低成本多级孔TS-1的制备及其氧化脱硫性能[J]. 无机盐工业, 2019,51(2):79-83.
[18]	He Z, Lin H, He P, et al. Effect of boric oxide doping on the stabi-lity and activity of a Cu-SiO₂ catalyst for vapor-phase hydrogena-tion of dimethyl oxalate to ethylene glycol[J]. Journal of Catalysis, 2011,277:54-63. doi: 10.1016/j.jcat.2010.10.010
[19]	Yang X Y, Chen L H, Li Y, et al. Hierarchically porous materials:Synjournal strategies and structure design[J]. Chemical Society Re-views, 2017,46(2), 481-558.
[20]	付辉, 李会鹏, 赵华, 等. WO₃-ZSM-5/MCM-41催化剂的合成及其催化氧化脱硫研究[J]. 无机盐工业, 2014,46(7):75-78.
[21]	Hossain K Z, Sayari A. Synjournal of onion-like mesoporous silica from sodium silicate in the presence of α,ω-diamine surfac-tant[J]. Microporous and Mesoporous Materials., 2008,114:387-394. doi: 10.1016/j.micromeso.2008.01.026
[22]	Serrano D P, Sanz R, Pizarro P, et al. Hierarchical TS-1 zeolite as an efficient catalyst for oxidative desulphurization of hydrocarbon fractions[J]. Applied Catalysis B:Environmental, 2014,146(3):35-42. doi: 10.1016/j.apcatb.2013.05.025
[23]	Xu J Q, Qin Y H, Wang H L, et al. Recent advances in copper-ba-sed zeolite catalysts with low-temperature activity for the selecti-vecatalytic reduction of NO_x with hydrocarbons[J]. New Journal of Chemistry, 2020,44:817-831. doi: 10.1039/C9NJ04735B
[24]	Wang Y C, Liu Z R, Tan C, et al. High catalytic activity of CuY ca-talysts prepared by high temperature anhydrous interaction for the oxidative carbonylation of methanol[J]. RSC Advances, 2020,10:3293-3300. doi: 10.1039/C9RA10501H
[25]	Bawaked S, Narasimharao K. Structural and catalytic properties of copper silicate nanomaterials[J]. Scientific Reports, 2020,10.Doi: 10.1038/s41598-020-57502-z. doi: 10.1038/s41598-020-80649-8 pmid: 33384438
[26]	陈魁. 实验设计与分析[M]. 北京: 清华大学出版社, 1995.

样品	比表面积/ （m²·g^-1）	孔体积/ （cm³·g^-1）	平均孔径/ nm
MS-1	420	0.43	2.65
0.5% Cu/MS-1	400	0.42	2.65
2.5% Cu/MS-1	387	0.41	2.66
5.5% Cu/MS-1	375	0.41	2.68
10.0% Cu/MS-1	368	0.38	2.71
14.0% Cu/MS-1	339	0.35	2.73

水平	因素
水平	A 时间/ h	B w（铜）/%	C m（催化剂）/mg	D 温度/K	E n（H₂O₂）/ n（苯酚）	F w（双氧水）/%
1	1.0	0.5	40	303	1.2	10
2	2.0	2.5	50	313	1.4	15
3	3.0	5.5	60	323	1.6	20
4	4.0	10.0	70	333	1.8	25
5	5.0	14.0	80	343	2.0	30

实验编号	因素						苯二酚产率/%
实验编号	A	B	C	D	E	F	苯二酚产率/%
1	1	1	1	1	1	1	5.6
2	1	2	2	2	2	2	15.2
3	1	3	3	3	3	3	26.4
4	1	4	4	4	4	4	19.1
5	1	5	5	5	5	5	8.2
6	2	1	2	3	4	5	20.9
7	2	2	3	4	5	1	10.6
8	2	3	4	5	1	2	15.5
9	2	4	5	1	2	3	10.8
10	2	5	1	2	3	4	13.5
11	3	1	3	5	2	4	11.2
12	3	2	4	1	3	5	16.5
13	3	3	5	2	4	1	14.5
14	3	4	1	3	5	2	9.5
15	3	5	2	4	1	3	20.5
16	4	1	4	2	5	3	24.8
17	4	2	5	3	1	4	35.8
18	4	3	1	4	2	5	43.7
19	4	4	3	5	3	1	6.2
20	4	5	2	1	4	2	9.2
21	5	1	5	4	3	2	15.7
22	5	2	1	5	4	3	5.6
23	5	3	2	1	5	4	20.2
24	5	4	3	2	2	5	17.2
25	5	5	4	3	1	1	9.1
K₁	74.5	78.2	77.9	62.3	86.5	46.0	∑K_i=405.5
K₂	71.3	83.7	86.0	85.2	98.1	65.1
K₃	72.2	120.3	71.6	101.7	78.3	88.1
K₄	119.7	62.8	85.0	109.6	69.3	99.8
K₅	67.8	60.5	85.0	46.7	73.3	106.5
K₁/5	14.9	15.6	15.6	12.5	17.3	9.2
K₂/5	14.3	16.7	17.2	17.0	19.6	13.0
K₃/5	14.4	24.1	14.3	20.3	15.7	17.6
K₄/5	23.9	12.6	17.0	21.9	13.9	20.0
K₅/5	13.6	12.1	17.0	9.3	14.7	21.3
R	10.3	12.0	3.1	12.6	5.7	12.1

催化剂重复使用次数	苯二酚产率/ %	苯二酚选择性/%	w（铜）/ %
0	47.2	86.7	5.24
1	44.6	86.3	5.20
2	43.8	86.8	5.18
3	43.4	87.0	5.16
4	43.2	86.6	5.15

National Inorganic Salts Information Center

Inorganic Acid-Base-Salt Committee of CIESC

Synthesis of dihydroxybenzenes by hydroxylation of phenol over Cu/ MS-1 with mesoporous

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 10

References 26

Related Articles 15

Metrics

Comments

Recommended 0

[1]	JIN Suna, LÜ Ruiliang. Research progress of heterogeneous catalytic ozonation for industrial wastewater treatment [J]. Inorganic Chemicals Industry, 2024, 56(3): 28-38.
[2]	CHEN Xingliang, FAN Wenjuan, CHANG Hui, HUANG Haiping, JIANG Zhiqiang. Study on collaborative strategy between Fe³⁺ and Ni-based metal-organic frameworks for boosting electrocatalytic oxygen evolution [J]. Inorganic Chemicals Industry, 2024, 56(2): 152-158.
[3]	JIN Shengshi, LIU Kaijie, LIU Qiuwen, ZHANG Yibo, YANG Xiangguang. Study on catalytic performance of phosphoric acid modified CeO₂ nanorod supported Pt catalyst for propane combustion [J]. Inorganic Chemicals Industry, 2024, 56(1): 141-148.
[4]	GUO Zini, QU Jiyan, LUO Jianhong. Oxidation of NO _x by low-temperature plasma using catalysts with different band gaps [J]. Inorganic Chemicals Industry, 2023, 55(9): 126-133.
[5]	LIU Wei, XU Yan, CHEN Yongsheng, SUN Chunhui, ZHANG Jingcheng, ZHU Jinjian, LIU Yang. Effect of alkaline earth metals on performance of Cu/Al₂O₃ ester hydrogenation catalyst [J]. Inorganic Chemicals Industry, 2023, 55(9): 140-144.
[6]	MA Chao, HU Jieqiong, XIE Ming, CHEN Yongtai, ZHANG Qiao, CHEN Song, FANG Jiheng, QIU Leqi. Research progress of preparation of Pt-Au-Ni nanoalloys [J]. Inorganic Chemicals Industry, 2023, 55(9): 26-32.
[7]	YANG Bo, LIANG Zhiyan, LIU Wenyuan, CAO Jiazhen, LIU Xinyue, XING Mingyang. Research progress of application of molybdenum-based catalytic materials for water pollution control [J]. Inorganic Chemicals Industry, 2023, 55(8): 1-12.
[8]	MA Zhiyuan, LÜ Dawei, WANG Hui, JIN Nannan, ZHU Jinjian, ZHANG Jingcheng. Industrial application of THDS-2/3 catalyst in capacity expansion of hydrofining plant [J]. Inorganic Chemicals Industry, 2023, 55(8): 140-144.
[9]	CHEN Junxue, MO Jianxin, ZHOU Zhiyu, LI Zhonglin, WANG Ding, LI Yuping, HU Yongjun, JIANG Xuexian, LI Yibing. Study on synthesis of NaFe _x Cr _y （SO₄）₂（OH）₆ and their electrochemical properties [J]. Inorganic Chemicals Industry, 2023, 55(8): 71-76.
[10]	WANG Yansu, LIU Guozhu, YU Haibin. Research progress of platinum-based propane dehydrogenation catalysts [J]. Inorganic Chemicals Industry, 2023, 55(7): 1-9.
[11]	LU Qin, FANG Wei, ZHAO Lei. Preparation of graphitized carbon modified carbonized rice husk foam and its solar steam generation performance [J]. Inorganic Chemicals Industry, 2023, 55(7): 122-129.
[12]	JIA Yuhong, HU Zhongpan, WANG Kunyuan, HAN Jingfeng, WEI Yingxu, LIU Zhongmin. Co anchored on silanol nests of S-1 zeolite for propane dehydrogenation to propylene [J]. Inorganic Chemicals Industry, 2023, 55(5): 121-127.
[13]	LI Tong, YIN Hongfeng. Study on controllable preparation of nickel phyllosilicate nanotubes catalysts and their catalytic performance [J]. Inorganic Chemicals Industry, 2023, 55(5): 128-136.
[14]	ZHANG Yongkun, CHANG Yang, LI Xiaoguo, LIU Yan, XING Changxin, GAO Jinping, XIAO Jiawang, HOU Zhanggui. Study on modification of HZSM-5 catalyst and its pilot catalytic performance for alkylation of benzene with dilute ethylene [J]. Inorganic Chemicals Industry, 2023, 55(5): 137-142.
[15]	FENG Xiaoqian, ZHAO Yilin, ZHAO Yonghua, ZHANG Qijian, WANG Huan, MENG Qingrun. Recent progress of modified montmorillonited-based catalysts [J]. Inorganic Chemicals Industry, 2023, 55(5): 24-30.