氯化锌-水蒸气协同活化玉米芯制活性炭的研究

doi:10.19964/j.issn.1006-4990.2023-0220

Abstract

Abstract:

Zinc chloride activated carbon（ZnAC） with optimal methylene blue（MB） adsorption performance was prepared from corn cob of Ningxia agricultural waste.Based on these conditions，zinc chloride and water vapor were used to prepare activated carbon（ZnHAC） at different activation temperatures.The structure and surface properties of ZnAC and ZnHAC were analyzed by BET，XRD，FT-IR，and SEM to elucidate the activation mechanism.The results showed that the optimum conditions for ZnCl₂ activation were temperature of 500 ℃，activation time of 1 h，and zinc feed mass ratio of 1.5∶1.The specific surface area of activated carbon was 2 299.75 m²/g，the cumulative pore volume was 1.28 cm³/g，and the adsorption capacity of MB was 531.56 mg/g.The mesoporous rate of the activated carbon was up to more than 95%，and the mesoporous rate was increased with the increase in temperature，indicating that increasing temperature was conducive to the formation of mesoporous.At the same temperature，compared with ZnAC _T_-1.5-1，the specific surface area and pore volume of ZnHAC _T_-1.5-1 increased significantly after water vapor was introduced，and the specific surface area of ZnHAC_800-1.5-1 was increased by 349 m²/g compared with ZnAC_800-1.5-1，and mesoporous pore volume，total pore volume，and pore size were nearly doubled，respectively.ZnHAC_800-1.5-1 activated carbon surface contained more amorphous carbon.The activation effect of water vapor at high temperatures was more pronounced.The vapor made the activation effect more significant，because of enriching the structure of activated carbon and the oxygen-containing functional groups on the surface of activated carbon，and increasing of the disordered degree of carbon structure.

Key words: corncob, zinc chloride, water vapor, activated carbon, adsorption

CLC Number:

TQ132.41

XU Rongsheng, MENG Ze, FENG Qian, WANG Ping, SUN Dong, LI Mei. Study on preparation of activated carbon from corn cob by zinc chloride and water vapor[J]. Inorganic Chemicals Industry, 2023, 55(12): 119-127.

Figures/Tables 17

Fig.1

Fig.2

Table 1

Fig.3

Fig.4

Fig.5

Table 2

Fig.6

Fig.7

Fig.8

Table 3

Fig.9

Fig.10

Table 4

Fig.11

Fig.12

Fig.13

References 20

1	YANG Xiaomei， CHENG Leilei， HUANG Xianlei， et al. Incentive mechanism to promote corn stalk return sustainably in Henan，China［J］. Science of the Total Environment， 2020， 738：139775. doi: 10.1016/j.scitotenv.2020.139775
2	ZHANG Juan， FAN Kaixuan， WANG Pingping， et al. Enhancement of the adsorption of bilirubin on activated carbon via modification［J］. Results in Materials， 2021， 9：100172. doi: 10.1016/j.rinma.2021.100172
3	LIU Y， XU Xinrui， QU Bin， et al. Study on adsorption properties of modified corn cob activated carbon for mercury ion［J］. Energies， 2021， 14（15）：4483. doi: 10.3390/en14154483
4	JANUSZEWICZ K， KAZIMIERSKI P， KLEIN M， et al. Activated carbon produced by pyrolysis of waste wood and straw for potential wastewater adsorption［J］. Materials， 2020， 13（9）：2047. doi: 10.3390/ma13092047
5	TSAI W T， JIANG T J. Optimization of physical activation process for activated carbon preparation from water caltrop husk［J］. Biomass Conversion and Biorefinery， 2023， 13（8）：6875-6884. doi: 10.1007/s13399-021-01729-x
6	杨权成，张开永，郭德，等. 介孔硅酸钙吸附亚甲基蓝性能研究［J］. 无机盐工业， 2021， 53（10）：86-91.
	YANG Quancheng， ZHANG Kaiyong， GUO De， et al. Research on adsorption properties of methylene blue by mesoporous calcium silicate［J］. Inorganic Chemicals Industry， 2021， 53（10）：86-91.
7	MATSUZAWA F， AMANO Y， MACHIDA M. Phosphate ion adsorption characteristics of PAN-based activated carbon prepared by zinc chloride activation［J］. International Journal of Environmental Science and Technology， 2022， 19（9）：8159-8168. doi: 10.1007/s13762-021-03695-3
8	SHOAIB A G M， EL-SIKAILY A， NEMR A EL， et al. Preparation and characterization of highly surface area activated carbons followed type Ⅳ from marine red alga（Pterocladia capillacea） by zinc chloride activation［J］. Biomass Conversion and Biorefinery， 2022， 12（6）：2253-2265. doi: 10.1007/s13399-020-00760-8
9	NEMR A EL， ABOUGHALY R M， SIKAILY A EL， et al. Microporous-activated carbons of type I adsorption isotherm derived from sugarcane bagasse impregnated with zinc chloride［J］. Carbon Letters， 2022， 32（1）：229-249. doi: 10.1007/s42823-021-00270-1
10	Chairunnisa， TAKATA N， THU K， et al. Camphor leaf-derived activated carbon prepared by conventional physical activation and its water adsorption profile［J］. Carbon Letters， 2021， 31（4）：737-748. doi: 10.1007/s42823-020-00204-3
11	徐荣声，冯倩，孟泽，等. 枸杞杆制活性炭对亚甲基蓝的吸附研究［J］. 无机盐工业， 2022， 54（12）：106-112，118.
	XU Rongsheng， FENG Qian， MENG Ze， et al. Study on adsorption of methylene blue by activated carbon prepared by wolfberry stems［J］. Inorganic Chemicals Industry， 2022， 54（12）：106-112，118.
12	金春江，王鲁元，陈惠敏，等. 一步快速活化法制备生物质活性炭及其对乙酸乙酯的吸附再生［J］. 化工进展， 2021， 40（S1）：446-455. doi: 10.16085/j.issn.1000-6613.2020-2359
	JIN Chunjiang， WANG Luyuan， CHEN Huimin， et al. Preparation of biomass activated carbon by one step rapid activation and its adsorption regeneration for ethyl acetate［J］. Chemical Industry and Engineering Progress， 2021， 40（S1）：446-455. doi: 10.16085/j.issn.1000-6613.2020-2359
13	BORGHEI S A， ZARE M H， AHMADI M， et al. Synthesis of multi-application activated carbon from oak seeds by KOH activation for methylene blue adsorption and electrochemical supercapacitor electrode［J］. Arabian Journal of Chemistry， 2021， 14（2）：102958. doi: 10.1016/j.arabjc.2020.102958
14	YASEEN M， ULLAH S， AHMAD W， et al. Fabrication of Zn and Mn loaded activated carbon derived from corn cobs for the adsorptive desulfurization of model and real fuel oils［J］. Fuel， 2021， 284：119102. doi: 10.1016/j.fuel.2020.119102
15	ZHANG Zhe， XU Lei， LIU Yani， et al. Efficient removal of methylene blue using the mesoporous activated carbon obtained from mangosteen peel wastes：Kinetic，equilibrium，and thermodynamic studies［J］. Microporous and Mesoporous Materials， 2021， 315：110904. doi: 10.1016/j.micromeso.2021.110904
16	LUO Mingke， LIN Hai， LI Bing， et al. A novel modification of lignin on corncob-based biochar to enhance removal of cadmium from water［J］. Bioresource Technology， 2018， 259：312-318. doi: S0960-8524(18)30426-7 pmid: 29573610
17	JANG J， MIRAN W， DIVINE S D， et al. Rice straw-based biochar beads for the removal of radioactive strontium from aqueous solution［J］. Science of the Total Environment， 2018， 615：698- 707. doi: 10.1016/j.scitotenv.2017.10.023
18	ZUBIR M H M， AHMAD ZAINI M A. Twigs-derived activated carbons via H₃PO₄/ZnCl₂ composite activation for methylene blue and Congo red dyes removal［J］. Scientific Reports， 2020， 10：14050. doi: 10.1038/s41598-020-71034-6
19	ZHU Jiang， LI Yonghong， XU Lei， et al. Removal of toluene from waste gas by adsorption-desorption process using corncob-based activated carbons as adsorbents［J］. Ecotoxicology and Environmental Safety， 2018， 165：115-125. doi: S0147-6513(18)30844-3 pmid: 30195203
20	SARTOVA K， OMURZAK E， KAMBAROVA G， et al. Activated carbon obtained from the cotton processing wastes［J］. Diamond and Related Materials， 2019， 91：90-97. doi: 10.1016/j.diamond.2018.11.011

样品	V_mic/ （cm³·g^-1）	V_mes/ （cm³·g^-1）	V_tot/ （cm³·g^-1）	S_BET/ （m²·g^-1）	D_p/ nm	q_e/ （mg·g^-1）
ZnAC_400-1.5-1	0.37	0.40	0.77	1 771.66	2.18	489.24
ZnAC_500-1.5-1	0.06	1.22	1.28	2 299.75	2.23	531.56
ZnAC_600-1.5-1	0.15	1.04	1.19	2 040.72	2.33	519.82
ZnAC_700-1.5-1	0.11	0.88	0.99	1 802.30	2.34	493.67
ZnAC_800-1.5-1	0.11	0.90	1.01	1 682.62	2.40	485.02

样品	V_mic/ （cm³·g^-1）	V_mes/ （cm³·g^-1）	V_tot/ （cm³·g^-1）	S_BET/ （m²·g^-1）	D_p/ nm	q_e/ （mg·g^-1）
ZnAC_500-1.5-0.5	0.09	1.15	1.24	2 011.01	2.05	509.32
ZnAC_500-1.5-1	0.06	1.22	1.28	2 299.75	2.23	531.56
ZnAC_500-1.5-1.5	0.02	1.25	1.27	2 315.01	2.19	537.94
ZnAC_500-1.5-2	0.09	1.11	1.20	2 159.06	2.26	522.08
ZnAC_500-1.5-2.5	0.14	1.02	1.16	1 979.07	2.35	511.79

样品	V_mic/（cm³·g^-1）	V_mes/（cm³·g^-1）	V_tot/ （cm³·g^-1）	S_BET/ （m²·g^-1）	D_p/ nm	q_e/ （mg·g^-1）
ZnAC_500-0.5-1	0.36	0.40	0.76	1 460.53	2.07	476.91
ZnAC_500-1-1	0.39	0.63	1.02	2 005.23	2.04	519.73
ZnAC_500-1.5-1	0.06	1.22	1.28	2 299.75	2.23	531.56
ZnAC_500-2-1	0.27	1.32	1.59	2 093.03	2.78	526.82
ZnAC_500-2.5-1	0.16	1.48	1.64	1 803.37	3.64	507.49

样品	V_mic/ （cm³·g^-1）	V_mes/ （cm³·g^-1）	V_tot/ （cm³·g^-1）	S_BET/ （m²·g^-1）	D_p/ nm
ZnHAC_500-1.5-1	0.16	1.30	1.46	2 570.18	2.23
ZnHAC_600-1.5-1	0.15	1.44	1.59	2 240.53	2.34
ZnHAC_700-1.5-1	0.13	1.59	1.72	1 909.03	2.78
ZnHAC_800-1.5-1	0.12	2.21	2.33	2 031.98	4.58

[1]	XU Mengyao, ZHANG Xin, HE Kunpeng, HE Jian, JIANG Wei. Preparation of yttrium oxide and zirconium phosphate adsorbents from zirconium-yttrium waste and evaluation of their performance [J]. Inorganic Chemicals Industry, 2024, 56(3): 116-124.
[2]	LI Qiaoyun, HUANG Xiuxing, WEI Wenye, CHEN Zhen. Study on adsorption of methylene blue by activated carbon with acid/alkali synergistically modified fly ash [J]. Inorganic Chemicals Industry, 2024, 56(3): 131-136.
[3]	LI Yang, LOU Feijian, SUI Xin, LI Keyan, LIU Fei, GUO Xinwen. Preparation of amine-functionalized fumed SiO₂ materials and their performance for CO₂ adsorption [J]. Inorganic Chemicals Industry, 2024, 56(2): 38-43.
[4]	ZHANG Li, ZHANG Dan, PAN Hongyan, DONG Yonggang, LI Wenfei, QIN Hong. Study on preparation of low ash activated carbon by phosphoric acid method [J]. Inorganic Chemicals Industry, 2024, 56(2): 95-103.
[5]	ZHANG Ying, LI Jun, JIN Yang, HUANG Meiying. Study on pyrolysis regeneration of activated carbon for Tributyl phosphate decolorization [J]. Inorganic Chemicals Industry, 2024, 56(1): 59-66.
[6]	YAN Zhen, QIU Zhaofu, JIN Xibiao, WANG Yuan, LIU Chang, YANG Ji. Study on 4A molecular sieve loaded with Ce and γ-Fe₂O₃ for removal of Sb（Ⅲ） and Sb（Ⅴ） in water [J]. Inorganic Chemicals Industry, 2024, 56(1): 81-89.
[7]	ZHOU Shiqi, WANG Tao, JING Fangli, LUO Shizhong. Study on performance of magnesium nitrate-modified carbon molecular sieve for separation of nitrogen/methane [J]. Inorganic Chemicals Industry, 2023, 55(9): 75-80.
[8]	LI Chao, WANG Liping, DAI Yin, GAO Guimei, ZHANG Yunfeng, HONG Yu, XU Lijun, CUI Yongjie. Study on alkali fusion hydrothermal synthesis of 13X zeolite from high silicon tailings and its adsorption on lead，copper and zinc ions [J]. Inorganic Chemicals Industry, 2023, 55(9): 88-93.
[9]	WANG Yingnan, SHENG Linlin, HUANG Juan, HUANG Zhanbin. Study on adsorption performance of lead from water by coal-fired slag [J]. Inorganic Chemicals Industry, 2023, 55(8): 109-115.
[10]	TANG Yifu, CAO Changchun, LÜ Peng. Study on adsorption of cadmium-humic acid by hydroxyiron oxide [J]. Inorganic Chemicals Industry, 2023, 55(8): 124-131.
[11]	HAN Hongjing, ZHANG Jingze, LAMAO Zhuoma, HAN Jizhe, WU Yongmin, TANG Weiping. Preparation of Al-Co co-doped lithium manganese oxide and its adsorption performance of lithium [J]. Inorganic Chemicals Industry, 2023, 55(7): 38-44.
[12]	FAN Fangfang, TONG Zhongkai, ZUO Weiyuan. Study on adsorption of tetracycline from wastewater by calcium modified peanut shell biochar [J]. Inorganic Chemicals Industry, 2023, 55(6): 109-115.
[13]	TIAN Yuling, CHENG Yang, HAN Rong, ZHOU Mei, WANG Chengjie, GE Qiangru. Effect of CaO on heavy metals stability and adsorption properties of sludge-derived biochar [J]. Inorganic Chemicals Industry, 2023, 55(6): 124-129.
[14]	FU Minglian, CEN Jianmei, CHEN Zhangxu. Study on preparation of magnetic SiO₂/chitosan composite aerogel and its adsorption for Cu²⁺ [J]. Inorganic Chemicals Industry, 2023, 55(6): 70-77.
[15]	XU Chunhui, WANG Feng, LING Changjian, WANG Zirui, TANG Zhongfeng. Research progress of CO₂ capture by metal oxides modified by molten salts [J]. Inorganic Chemicals Industry, 2023, 55(5): 1-7.

National Inorganic Salts Information Center

Inorganic Acid-Base-Salt Committee of CIESC

Study on preparation of activated carbon from corn cob by zinc chloride and water vapor

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 17

References 20

Related Articles 15

Metrics

Comments

Recommended 0