水/二氧化碳气氛下酒糟催化气化反应特性的研究

doi:10.19964/j.issn.1006-4990.2022-0243

摘要/Abstract

摘要：

在固定床气化装置中，以赤泥为催化剂、水/二氧化碳为气化剂对酒糟进行气化实验。研究了赤泥添加量、气化温度和V（水）/V（二氧化碳）对酒糟气化活性的影响，并对水/二氧化碳共气化协同机理进行了探讨。结果表明：当赤泥添加量为20%（质量分数）时气化活性最佳；升高气化温度有利于提高气化反应活性；随着V（水）/V（二氧化碳）的增大，合成气产量、n（氢气）/n（一氧化碳）均增加，分别达到270.7 mmol/g和6.67；在水/二氧化碳混合气氛下共气化反应产生了明显的协同效应，协同因子在60%水-40%二氧化碳（体积分数）时达到峰值。拉曼光谱、扫描电子显微镜及比表面积分析表明：水/二氧化碳混合气氛下酒糟焦无定形碳和非晶碳结构的破坏程度比在纯水或二氧化碳中更严重，验证了二氧化碳和水在酒糟气化中存在协同效应；二氧化碳更容易在酒糟焦表面发生气化反应，形成大量微孔使其比表面积增加；水炭渗透力较强有利于形成中孔；在水/二氧化碳混合气氛下，二氧化碳与水产生的交互作用促进了孔结构的发育，使酒糟焦的微孔发展为中孔和大孔并促使气化反应向酒糟颗粒内部发展，这是协同效应产生的主要原因。

关键词: 酒糟, 协同效应, 水/二氧化碳, 催化气化, 赤泥

Abstract:

The gasification experiments on distillers′ grain was conducted in a fixed-bed gasification plant with red mud as the catalyst and H₂O/CO₂ as the gasification agent.The effects of red mud addition，gasification temperature and H₂O/CO₂ ratio on the gasification characteristics of the distillers′ grain were investigated and the synergistic mechanism of H₂O/CO₂co-gasification was discussed.The results showed that the gasification activity was best when red mud addition was 20%（mass fraction）.The increased gasification temperature was beneficial to the gasification reaction activity.When V（H₂O）/V（CO₂） was increased，the syngas yield and n（H₂）/n（CO） was also increased，up to 270.7 mmol/g and 6.67.The co-gasification under H₂O/CO₂ mixed atmosphere produced significant synergistic effect，and the synergistic factor was peaked at 60% H₂O-40% CO₂（volume fraction）.Raman，SEM and BET analysis showed that the amorphous carbon and amorphous carbon structure of the distillers′ grain coke in the H₂O/CO₂mixed atmosphere was more severely damaged than that in pure H₂O or CO₂，which verified that CO₂and H₂O existed the synergistic effect of in the distillers′ grain gasification.CO₂ was more prone to gasification on the surface of distiller′s grains coke，forming a large number of micropores to increase the specific surface area.Carbon with H₂O had stronger permeability to facilitate the formation of mesopores.In H₂O/CO₂ mixed atmosphere，the interaction between CO₂ and H₂O made the micropores of distiller′s grains coke to develop into mesopores and macropores and promoted the gasification reaction to the interior of distillers′ grains granule，which triggered the synergistic effect.

Key words: distillers′^grains, synergistic effect, H₂O/CO₂, catalytic gasification, red mud

中图分类号:

O643.3

李松鸿,周松华,赵爱明,董文燕,姜春燕,曹阳,敖先权. 水/二氧化碳气氛下酒糟催化气化反应特性的研究[J]. 无机盐工业, 2023, 55(2): 132-140.

LI Songhong,ZHOU Songhua,ZHAO Aiming,DONG Wenyan,JIANG Chunyan,CAO Yang,AO Xianquan. Study on catalytic gasification reaction of distillers′grains under H₂O/CO₂ atmosphere[J]. Inorganic Chemicals Industry, 2023, 55(2): 132-140.

图/表 14

表1

表2

图1

图2

图3

表3

图4

图5

图6

图7

表 4

图8

表 5

图9

参考文献 34

1	中华人民共和国国家统计局.中国统计年鉴[M].北京：中国统计出版社，2020.
	National Bureau of Statistics of the People's Republic of China.China Statistical Yearbook[M].Beijing：China Statistics Press，2020.
2	王兆夺，祝超伟，于东生.全球气候变化背景下对“温室效应”的思考[J].辽宁师范大学学报：自然科学版，2017，40（3）：407-414.
	WANG Zhaoduo， ZHU Chaowei， YU Dongsheng.On“Greenhouse Effect”under the background of global climate change[J].Journal of Liaoning Normal University：Natural Science Edition，2017，40（3）：407-414.
3	IRFAN M， ELAVARASAN R M， AHMAD M，et al.Prioritizing and overcoming biomass energy barriers：Application of AHP and G-TOPSIS approaches[J].Technological Forecasting and Social Change，2022，177.Doi：10.1016/j.techfore.2022.121524 . doi: 10.1016/j.techfore.2022.121524
4	聂永增.对于酒糟综合利用现状及创新应用的思考[J].轻工科技，2021，37（9）：11-12.
	NIE Yongzeng.Thoughts on the comprehensive utilization of distiller's grains and its innovative application[J].Light Industry Science and Technology，2021，37（9）：11-12.
5	张德成，敖先权，陈前林，等.酒糟与煤焦在CO₂气氛下的共气化活性[J].过程工程学报，2016，16（4）：629-633.
	ZHANG Decheng， AO Xianquan， CHEN Qianlin，et al.Co-gasification characteristics of distillery residue with coal char in CO₂ atmosphere[J].The Chinese Journal of Process Engineering，2016，16（4）：629-633.
6	WANG Jiaxing， ZHANG Shuping， XU Dan，et al.Catalytic activity evaluation and deactivation progress of red mud/carbonaceous catalyst for efficient biomass gasification tar cracking[J].Fuel，2022，323.Doi：10.1016/j.fuel.2022.124278 . doi: 10.1016/j.fuel.2022.124278
7	LV Jiwei， AO Aianquan， LI Qian，et al.Steam co-gasification of different ratios of spirit-based distillers′grains and anthracite coal to produce hydrogen-rich gas[J].Bioresource Technology，2019，283：59-66.
8	ZHAO Aiming， LV Jiwei， CHEN Qianlin，et al.Spirit-based distillers’grains and red mud synergistically catalyse the steam gasification of anthracite to produce hydrogen-rich synthesis gas[J].International Journal of Hydrogen Energy，2021，46（1）：314-323.
9	PHOUNGLAMCHEIK A， BACKEBO M， ROBINSON R，et al.The significance of intraparticle and interparticle diffusion during CO₂ gasification of biomass char in a packed bed[J].Fuel，2022，3.Doi：1010.1016/j.fuel.2021.122302 . doi: 1010.1016/j.fuel.2021.122302
10	CAI Jianjun， ZHANG Wenheng， LUO Ming，et al.Evaluation of the CO₂ gasification of residual char under a regeneration atmosphere via calcium-based chemical looping gasification[J].Chemical Engineering and Processing-Process Intensification，2021，168.Doi：10.1016/j.cep.2021.108564 . doi: 10.1016/j.cep.2021.108564
11	NILSSON S， GOMEZ-BAREA A， OLLEROll P.Gasification of char from dried sewage sludge in fluidized bed：Reaction rate in mixtures of CO₂ and H₂O[J].Fuel，2013，105：764-768.
12	CHANG Guozhang， YAN Ximin， QI Pengyu，et al.Characteristics of reactivity and structures of palm kernel shell（PKS） biochar during CO₂/H₂O mixture gasification[J].Chinese Journal of Chemical Engineering，2018，26（10）：2153-2161.
13	关昱，张彦迪，刘银河.CO₂/H₂O气氛下红沙泉煤中碱（土）金属的分布及其气化反应特性[J].燃料化学学报，2022，50（6）：674-682.
	GUAN Yu， ZHANG Yandi， LIU Yinhe.Distribution of alkaline（earth） metals and gasification reaction characteristics of HSQ coal under CO₂/H₂O atmosphere[J].Journal of Fuel Chemistry and Technology，2022，50（6）：674-682.
14	HOWANIEC N.Temperature induced development of porous structure of bituminous coal chars at high pressure[J].Journal of Sustainable Mining，2016，15（3）：120-124.
15	GLENK G， REICHELSTEIN S.Economics of converting renewable power to hydrogen[J].Nature Energy，2019，4（3）：216-222.
16	GUIZANI C， ESCUDERO-SANZ F J， SALVADOR S.The gasification reactivity of high-heating-rate chars in single and mixed atmospheres of H₂O and CO₂ [J].Fuel，2013，108：812-823.
17	MASSOUDI-FARID M， HWANG J.Competition between H₂O and CO₂ for active sites during co-gasification of bituminous coal and pineapple sawdust in an atmosphere containing H₂O，CO₂，H₂，and CO[J].Fuel，2017，207：198-203.
18	ROBERTS D G， HARRIS D J.Char gasification kinetics in mixtures of CO₂ and H₂O：The role of partial pressure in determining the extent of competitive inhibition[J].Energy & Fuels，2014，28（12）：7643-7648.
19	UMEMOTO S， KAJITANI S， HARA S.Modeling of coal char gasification in coexistence of CO₂ and H₂O considering sharing of active sites[J].Fuel，2013，103：14-21.
20	BAI Yonghui， LV Peng， YANG Xuhao，et al.Gasification of coal char in H₂O/CO₂ atmospheres：Evolution of surface morphology and pore structure[J].Fuel，2018，218：236-246.
21	GAO Meiqi， LV Peng， YANG Zhirong，et al.Effects of Ca/Na compounds on coal gasification reactivity and char characteristics in H₂O/CO₂ mixtures[J].Fuel，2017，206：107-116.
22	LIU Rui， ZHANG Yan， ZHENG Ling，et al.Some new insights into the synergy occurring during char gasification in CO₂/H₂O mixtures[J].Fuel，2020，268.Doi：10.1016/j.fuel.2020.117307 . doi: 10.1016/j.fuel.2020.117307
23	GIL M V， RIAZA J， ÁLVAREZ L，et al.Biomass devolatilization at high temperature under N₂ and CO₂：Char morphology and reactivity[J].Energy，2015，91：655-662.
24	WEI Juntao， GUO Qinghua， HE Qing，et al.Co-gasification of bituminous coal and hydrochar derived from municipal solid waste：Reactivity and synergy[J].Bioresource Technology，2017，239：482-489.
25	KORUS A， RAVENNI G， LOSKA K，et al.The importance of inherent inorganics and the surface area of wood char for its gasification reactivity and catalytic activity towards toluene conversi- on[J].Renewable Energy，2021，173：479-497.
26	MASSOUDI FARID M， JEONG H J， HWANG J.Kinetic study on coal-biomass mixed char co-gasification with H₂O in the presence of H₂ [J].Fuel，2016，181：1066-1073.
27	PARTHASARATHY P， K.S NARAYANAN.Hydrogen production from steam gasification of biomass：Influence of process parameters on hydrogen yield-A review[J].Renewable Energy，2014，66：570-579.
28	ELLIS N， MASNADI M S， ROBERTS D G.Mineral matter interactions during co-pyrolysis of coal and biomass and their impact on intrinsic char co-gasification reactivity[J].Chemical Engineering Journal，2015，279：402-408.
29	XU Deliang， YANG Liu， DING Kuan，et al.Mini-review on char catalysts for tar reforming during biomass gasification：The importance of char structure[J].Energy & Fuels，2020，34（2）：1219-1229.
30	JAYARAMAN K， GOKALP I， JEYAKUMAR S.Estimation of synergetic effects of CO₂ in high ash coal-char steam gasificati-on[J].Applied Thermal Engineering，2017，110：991-998.
31	黄艳琴，苏德仁，阴秀丽，等.木粉焦CO₂和H₂O气化过程孔结构及反应性的变化[J].燃料化学学报，2011，39（6）：432- 437.
	HUANG Yanqin， SU Deren， YIN Xiuli，et al.Changes of pore structure and reactivity during CO₂ and H₂O gasification of fir char[J].Journal of Fuel Chemistry and Technology，2011，39（6）：432-437.
32	SHENG Changdong.Char structure characterised by Raman spectroscopy and its correlations with combustion reactivity[J].Fuel，2007，86（15）：2316-2324.
33	LI Xiao， CHANG Guozhang， YANG Laishun，et al.Enhancement of coke gasification by lignite and a low-cost Fe/red mud catalyst to produce syngas[J].Journal of the Energy Institute，2021，98：116-123.
34	FENG Dongdong， ZHAO Yijun， ZHANG Yu，et al.Catalytic mechanism of ion-exchanging alkali and alkaline earth metallic species on biochar reactivity during CO₂/H₂O gasification[J].Fuel，2018，212：523-532.

工业分析，w/%					元素分析，w/%
M_ad	V_d	A_d	F_cd		C	H	N	S	O*
9.44	69.47	5.00	16.09		60.10	4.82	3.26	0.28	31.09

不同气氛下的样品	理论反应性指数	实际反应性指数	协同因子
100%CO₂	0.014 6	0.014 6	1.000
20%H₂O-80%CO₂	0.015 1	0.021 4	1.418
40%H₂O-60%CO₂	0.015 8	0.024 2	1.535
60%H₂O-40%CO₂	0.016 4	0.028 1	1.712
80%H₂O-20%CO₂	0.016 9	0.026 4	1.562
100%H₂O	0.017 5	0.017 5	1.000

样品	S_BET （m²·g^-1）	S_micro （m²·g^-1）	V_micro （cm³·g^-1）	V_meso （cm³·g^-1）	L_mpps/ nm	V_total （cm³·g^-1）
100%CO₂	661	290	0.125	0.193	4.617	0.376
100%H₂O	623	265	0.116	0.387	7.007	0.503
60%H₂O-40%CO₂	576	238	0.092	0.413	8.262	0.567
80%H₂O-20%CO₂	615	255	0.112	0.361	6.215	0.516

不同气氛下的气化半焦	A_D3/A_G	A_D1/A_G
100%CO₂	3.583	5.345
100%H₂O	2.076	4.416
60%H₂O-40%CO₂	1.398	2.818
80%H₂O-20%CO₂	1.866	3.099

[1]	徐文珍,李灿华,季洪峰,李子木,吴朝阳,李明晖. 赤泥在回收金属和建筑材料领域的研究进展[J]. 无机盐工业, 2023, 55(2): 10-18.
[2]	潘思呈,徐红彬,张红玲,董玉明,张宏军,娄太平. 赤泥硫酸铵焙烧浸出液水解制备偏钛酸的研究[J]. 无机盐工业, 2023, 55(2): 85-91.
[3]	鲁镜镜,谢燕,李宸,蒙梅,冯伦伟. 载镧磁化赤泥处理含磷废水的研究[J]. 无机盐工业, 2023, 55(2): 99-105.
[4]	李向阳,刘紫威,李克艳,郭新闻. FeMn-MOF/CN异质结光芬顿催化剂制备及性能研究[J]. 无机盐工业, 2022, 54(12): 126-132.
[5]	潘祖德,刘琦,曹阳,陈前林,杨敏,谢燕. 磷石膏基矿井充填材料制备及其性能研究[J]. 无机盐工业, 2022, 54(11): 90-95.
[6]	皇志威,苏向东,张建刚,骆弟元,陈烨,李海嘉. 赤泥-磷石膏复合材料中重金属浸出研究[J]. 无机盐工业, 2022, 54(10): 133-140.
[7]	刘俊霞,杨艳蒙,王帅旗,刘盼,张茂亮,海然. 激发剂对赤泥地聚物砂浆力学性能的影响[J]. 无机盐工业, 2020, 52(6): 72-75.
[8]	马时成,梅再美,顾汉念,郭腾飞,代杨,王宁. 锰渣-赤泥吸附剂制备及其对铜（Ⅱ）吸附性能[J]. 无机盐工业, 2020, 52(3): 85-89.
[9]	海然,王帅旗,刘盼,刘俊霞. 热活化温度对氧化铝赤泥反应活性的影响及机理研究[J]. 无机盐工业, 2019, 51(9): 72-75.
[10]	董林辉,李杨,周雪芳,周勇,朱文渊,周小峰. 聚合硫酸铁铝的制备及除磷性能研究[J]. 无机盐工业, 2019, 51(5): 57-60.
[11]	海然, 刘俊霞, 李建伟. 氧化铝赤泥放射性及其屏蔽机制研究现状[J]. 无机盐工业, 2016, 48(9): 10-.
[12]	顾汉念, 崔姗姗, 王宁, 赵成东. 赤泥中碱的分布特征与淋滤效果研究[J]. 无机盐工业, 2016, 48(2): 45-.
[13]	纪利春, 相亚军. 电石渣烧结法从赤泥回收氧化铝[J]. 无机盐工业, 2016, 48(2): 68-.
[14]	朱晓波, 李望, 管学茂. 赤泥水浸脱碱实验及动力学研究[J]. 无机盐工业, 2016, 48(1): 41-.
[15]	陈红亮, 汪婷, 柯杨, 王胜碧. 赤泥中钠铁酸法浸出的工艺条件和机理探讨[J]. 无机盐工业, 2016, 48(1): 44-.

首页

全国无机盐信息中心

中国化工学会

无机酸碱盐专业委员会