无机盐工业
主管:中海油天津化工研究设计院有限公司
主办:中海油天津化工研究设计院有限公司
   中海油炼油化工科学研究院(北京)有限公司
   中国化工学会无机酸碱盐专业委员会
ISSN 1006-4990 CN 12-1069/TQ
环境·健康·安全

典型硫酸盐固废复合胶凝材料制备与微观特性研究

  • 余舟 ,
  • 何兆益 ,
  • 唐亮 ,
  • 何盛 ,
  • 肖海鑫 ,
  • 肖懿训
展开
  • 1.重庆交通大学土木工程学院,重庆 400074
    2.重庆交通大学交通运输学院,重庆 400074
余舟(1998— ),男,在读硕士研究生,主要从事道路材料方面的研究;E-mail:995929765@qq.com
何兆益(1965— ),男,教授,博士生导师,主要从事路面结构与新材料研究;E-mail:hzyzwb@cqjtu.edu

收稿日期: 2023-07-05

  网络出版日期: 2024-04-18

基金资助

重庆市科技局重点项目(cstc2021jscx-jbgs0029)

Study on preparation and microscopic properties of typical sulfate solid waste composite cementitious materials

  • YU Zhou ,
  • HE Zhaoyi ,
  • TANG Liang ,
  • HE Sheng ,
  • XIAO Haixin ,
  • XIAO Yixun
Expand
  • 1.School of Civil Engineering,Chongqing Jiaotong University,Chongqing 400074,China
    2.School of Traffic & Transportation,Chongqing Jiaotong University,Chongqing 400074,China

Received date: 2023-07-05

  Online published: 2024-04-18

摘要

硫酸盐类工业固废造成的环境污染和资源浪费问题引起了国内外学者的广泛关注,当前中国两种典型的硫酸盐类固废(电解锰渣和磷石膏)堆存量巨大,造成严重的环境污染,其无害化与资源化利用刻不容缓。依据电解锰渣、磷石膏两种固体废弃物的特性,利用电解锰渣和磷石膏结合矿渣制备复合胶凝材料,探究了磷石膏和水泥不同掺量对复合胶凝材料硬化体力学性能的影响。通过XRD、SEM和EDS分析了硬化体的物相组成和微观形貌变化特征,同时对硬化体进行毒性浸出测试。结果表明:硬化体各龄期强度随着水泥掺量增加而增大,硬化体各龄期强度随着磷石膏掺量增加而减小。复合胶凝材料较优配合比(质量分数)为电解锰渣为50%、磷石膏为20%、矿渣为30%,水泥外掺12%的硬化体28 d抗压强度为27.1 MPa,硫酸盐固废复合胶凝材料的水化产物主要为水化硅酸钙(C-S-H)凝胶和钙矾石(AFt)。养护至28 d的硬化体浸出液中可溶性Mn2+、NH4+-N、PO43-和重金属离子浓度稳定后满足GB 8978—1996《污水综合排放标准》的排放要求。

本文引用格式

余舟 , 何兆益 , 唐亮 , 何盛 , 肖海鑫 , 肖懿训 . 典型硫酸盐固废复合胶凝材料制备与微观特性研究[J]. 无机盐工业, 2024 , 56(4) : 90 -97 . DOI: 10.19964/j.issn.1006-4990.2023-0354

Abstract

The environmental pollution and resource waste caused by sulfate industrial solid wastes have attracted widespread attention from scholars at home and abroad.At present,two typical sulfate solid wastes in China,electrolytic manganese slag and phosphogypsum,have huge stockpiles and cause serious environmental pollution,so it is urgent to realize their harmless and resourceful utilization.Based on the characteristics of two kinds of solid wastes,electrolytic manganese slag and phosphogypsum were used to prepare composite cementitious materials by combining slag with electrolytic manganese slag and phosphogypsum,and the effects of different blending amounts of phosphogypsum and ordinary silicate cement on the mechanical properties of the composite cementitious materials were investigated.The physical composition and microscopic morphological changes of the hardened body were analyzed by XRD,SEM and EDS,and the toxicity leaching test was also conducted on the hardened body.The results showed that the strength of the hardened body at each age was increased with the increase of cement dosing,and the strength of the hardened body at each age was decreased with the increase of phosphogypsum dosing.The 28 d compressive strength of the composite cementitious materials with the ratio of 50% electrolytic manganese slag,20% phosphogypsum,30% slag and 12% cement admixture could reach 27.1 MPa,and the hydration products of sulfate solid waste composite cementitious materials were mainly hydrated calcium silicate(C-S-H) gel and calcium alumina(AFt).The concentration of soluble Mn2+,NH4+-N,PO43- and heavy metal ions in the leachate of the hardened body maintained to 28 d met the discharge requirements of GB 8978—1996“Comprehensive Wastewater Discharge Standards”after stabilization.

参考文献

1 何德军, 舒建成, 陈梦君, 等. 电解锰渣建材资源化研究现状与展望[J]. 化工进展202039(10):4227-4237.
  HE Dejun, SHU Jiancheng, CHEN Mengjun, et al. Current status and future prospects of electrolytic manganese residue reused as building materials[J]. Chemical Industry and Engineering Progress202039(10):4227-4237.
2 金修齐, 黄代宽, 赵书晗, 等. 电解锰渣胶凝固化研究进展及其胶结充填可行性探讨[J]. 矿物岩石地球化学通报202039(1):97-103.
  JIN Xiuqi, HUANG Daikuan, ZHAO Shuhan, et al. Research progress in cementation/solidification and possibility of consolidated backfilling of the electrolytic manganese residue[J]. Bulletin of Mineralogy,Petrology and Geochemistry202039(1):97-103.
3 CáNOVAS C R, MACíAS F, PéREZ-LóPEZ R, et al. Valorization of wastes from the fertilizer industry:Current status and future trends[J]. Journal of Cleaner Production2018174:678-690.
4 张峻, 解维闵, 董雄波, 等. 磷石膏材料化综合利用研究进展[J]. 材料导报202337(16):167-178.
  ZHANG Jun, XIE Weimin, DONG Xiongbo, et al. Research progress on comprehensive utilization of phosphogypsum for materials:A review[J]. Materials Reports202337(16):167-178.
5 WANG Jia, PENG Bing, CHAI Liyuan, et al. Preparation of electrolytic manganese residue-ground granulated blastfurnace slag cement[J]. Powder Technology2013241:12-18.
6 王继林, 龙广成, 董荣珍, 等. 掺电解锰渣砂浆的强度与微结构及碳排放分析[J]. 铁道科学与工程学报202320(4):1382-1391.
  WANG Jilin, LONG Guangcheng, DONG Rongzhen, et al. Analysis of strength,microstructure and carbon emission of mortar mixed with electrolytic manganese residue[J]. Journal of Railway Science and Engineering202320(4):1382-1391.
7 胡修权, 张立, 张晋, 等. 非煅烧磷石膏基胶凝材料的改性实验[J]. 无机盐工业202254(4):29-33.
  HU Xiuquan, ZHANG Li, ZHANG Jin, et al. Modification experiment of non-calcined phosphogypsum based cementitious materials[J]. Inorganic Chemicals Industry202254(4):29-33.
8 LAM N N. A study on super-sulfated cement using Dinh Vu phosphogypsum[J]. IOP Conference Series:Earth and Environmental Science2018143: 012016.
9 王星敏, 徐龙君, 胥江河, 等. 电解锰渣中锰的浸出条件及特征[J]. 环境工程学报20126(10):3757-3761.
  WANG Xingmin, XU Longjun, XU Jianghe, et al. Leaching conditions and characteristics of manganese from electrolytic manganese residue[J]. Chinese Journal of Environmental Engineering20126(10):3757-3761.
10 杨洪友, 王家伟, 王海峰, 等. 某电解锰渣免烧砖的抗压抗折性能研究[J]. 非金属矿201942(3):13-15.
  YANG Hongyou, WANG Jiawei, WANG Haifeng, et al. Study on compressive and flexural properties of the baking-free brick made from an electrolytic manganese slag[J]. Non-Metallic Mines201942(3):13-15.
11 谭明洋, 张西兴, 相利学, 等. 磷石膏作水泥缓凝剂的研究进展[J]. 无机盐工业201648(7):4-6.
  TAN Mingyang, ZHANG Xixing, XIANG Lixue, et al. Research progress of phosphorus gypsum as cement retarder[J]. Inorganic Chemicals Industry201648(7):4-6.
12 JIANG Guanzhao, WU Aixiang, WANG Yiming, et al. Low cost and high efficiency utilization of hemihydrate phosphogypsum:Used as binder to prepare filling material[J]. Construction and Building Materials2018167:263-270.
13 安树好. 高掺量矿渣水泥的研制及其早强激发机理的研究[D]. 唐山: 华北理工大学, 2008.
  AN Shuhao. Development of high-slag cement and study on the activation mechanism of its early-strength[D]. Tangshan: North China University of Science and Technology, 2008.
14 张歆, 刘方, 朱健, 等. 基于电解锰渣-磷石膏复合胶凝材料的制备与表征[J]. 硅酸盐通报202140(5):1610-1619.
  ZHANG Xin, LIU Fang, ZHU Jian, et al. Preparation and characterization of composite cementitious material based on electrolytic manganese residue-phosphogypsum[J]. Bulletin of the Chinese Ceramic Society202140(5):1610-1619.
15 白敏, 龙广成. 大掺量电解锰渣制备生态型低强度水泥基材料[J]. 新型建筑材料202350(6):55-60.
  BAI Min, LONG Guangcheng. Preparation of ecological cement-based materials with low strength by mixing large amount of electrolytic manganese residue[J]. New Building Materials202350(6):55-60.
16 万惠文, 王银, 戴鹏, 等. 磷石膏/矿粉复合过硫胶凝材料的制备研究[J]. 武汉理工大学学报201436(3):23-27.
  WAN Huiwen, WANG Yin, DAI Peng, et al. Study of phosphogysum/slag compound persulfate cementitious material[J]. Journal of Wuhan University of Technology201436(3):23-27.
17 刘冬梅, 王玮琦, 彭艳周, 等. 磷石膏—磷渣基复合胶凝材料强度和水化特性研究[J]. 金属矿山2022(9):230-237.
  LIU Dongmei, WANG Weiqi, PENG Yanzhou, et al. Study on the strength and hydration characteristics of phosphogypsum-phosphorus slag composite cementitious material[J]. Metal Mine2022(9):230-237.
18 XUE Fei, WANG Teng, ZHOU Min, et al. Self-solidification/stabilisation of electrolytic manganese residue:Mechanistic insigh-ts[J]. Construction and Building Materials2020255:118971.
19 石马刚, 柯国军, 邹品玉, 等. 碱-矿渣水泥的水化,力学及干缩性能研究进展[J]. 硅酸盐通报202241(1):162-173.
  SHI Magang, KE Guojun, ZOU Pinyu, et al. Research progress of hydration,mechanical and dry shrinkage properties of alkali-activated slag cement[J]. Bulletin of the Chinese Ceramic Society202241(1):162-173.
20 冯智广. 钛石膏基复合胶凝材料的性能研究与利用[D]. 杭州: 浙江大学, 2021.
  FENG Zhiguang. Study and utilization of properties of titanium gypsum-based composite cementitious materials[D]. Hangzhou: Zhejiang University, 2021.
21 王智, 郭清春, 蒋小花, 等. 电解锰渣对粉煤灰火山灰活性的硫酸盐激发[J]. 非金属矿201134(4):5-8.
  WANG Zhi, GUO Qingchun, JIANG Xiaohua, et al. Sulphate activating of electrolytic manganese residue to fly ash[J]. Non-Metallic Mines201134(4):5-8.
文章导航

/