Inorganic Chemicals Industry >
Study on separation of iron from chromium trichloride solution
Received date: 2022-10-17
Online published: 2023-08-25
Iron-chromium redox flow batteries have long cycle life，high stability and low cost，and are increasingly used in the field of large-scale electrical energy storage.The research was carried out on the recovery and utilization of failure electrolyte of iron-chromium flow battery.Fe was separated from a mixed solution of CrCl3 and FeCl3，and Cr and Fe were both recovered.The removal of iron ions from chromium trivalent system by oxalic acid precipitation method was studied，and the effects of oxalic acid addition amount，solution pH，reaction temperature and stirring rate on the removal rate of iron were investigated.The results showed that when the oxalic acid dosage was 1.2 times of the theoretical value，the solution pH was 3.0 and the reaction temperature was 25 ℃，the iron removal rate could reach more than 97%.The obtained solid phase was ferrous oxalate dihydrate with good crystal morphology and purity greater over 98%.The research could provide an effective way for the comprehensive utilization of the electrolyte of iron-chromium redox flow batteries.
LI Shuqi , LI Xinqian , FENG Haitao , LI Bo , NIU Zhengrong , DONG Yaping . Study on separation of iron from chromium trichloride solution[J]. Inorganic Chemicals Industry, 2023 , 55(8) : 91 -94 . DOI: 10.19964/j.issn.1006-4990.2022-0614
| 1 | 冯海涛，董亚萍，梁建，等.基于电化学法的铬盐清洁生产工艺研究［J］.盐湖研究，2019，27（4）：9-17. |
| FENG Haitao， DONG Yaping， LIANG Jian，et al.Study on the green production process of chromate based on electrochemical method［J］.Journal of Salt Lake Research，2019，27（4）：9-17. | |
| 2 | DERABLA T， AFFOUNE A M， CHELAGHMIA M L.Effects of PEG，PVP and SDS on the properties of chromium coatings prepared from trivalent chromium chloride baths using experimental design and multi-response optimisation［J］.Surface Engineering and Applied Electrochemistry，2019，55（3）：304-316. |
| 3 | 任丽丽.高效三价铬电镀工艺研究［D］.哈尔滨：哈尔滨工业大学，2011. |
| REN Lili.Technology of effective trivalent chromium plating［D］.Harbin：Harbin Institute of Technology，2011. | |
| 4 | BARKER W E， KENNEDY D J.The reduction of acetylene to ethylene by chromous chloride［J］.Transactions of the Electrochemical Society，1947，92（1）：391. |
| 5 | 纪柱.铬盐发展方向：开发铬盐新产品、新用途［J］.无机盐工业，2014，46（10）：1-7. |
| JI Zhu.Development direction of chromium salts：Development of new chromium products and uses［J］.Inorganic Chemicals Industry，2014，46（10）：1-7. | |
| 6 | ZHENG S， ZHANG Y， LI Z，et al.Green metallurgical processing of chromite［J］.Hydrometallurgy，2006，82（3/4）：157-163. |
| 7 | 张懿，李佐虎，王志宽，等.绿色化学与铬盐工业的新一代产业革命［J］.化学进展，1998，10（2）：172-178. |
| ZHANG Yi， LI Zuohu， WANG Zhikuan，et al.Green chemistry and new revolution of chromic salts industry［J］.Progress in Chemistry，1998，10（2）：172-178. | |
| 8 | 梅海军，王劲松，宋卫国，等.铬酸盐的高效、节能、清洁的制造方法：中国，101508466A［P］.2009-08-19. |
| 9 | 冯海涛，董亚萍，李武，等.电合成重铬酸钠用析氧阳极的研究进展［J］.无机盐工业，2011，43（11）：9-11. |
| FENG Haitao， DONG Yaping， LI Wu，et al.Research progress in oxygen evolution anodes used in electrosynthesis of sodium dichromate［J］.Inorganic Chemicals Industry，2011，43（11）：9-11. | |
| 10 | TIAN Sen.Production and characterization of chromium oxide （Cr2O3） via a facile combination of electrooxidation and calcination［J］.International Journal of Electrochemical Science，2019：8805-8818. |
| 11 | 李超.离子膜电解制备金属铬粉及阳极电溶高碳铬铁的研究［D］.哈尔滨：哈尔滨工业大学，2014. |
| LI Chao.Research on anode eletrochemical dissolution of high-carbon ferrochrome and electrodeposition of chromium in an ion-exchange membrane reactor［D］.Harbin：Harbin Institute of Tech-nology，2014. | |
| 12 | 董亚萍，冯海涛，李武，等.电解铬铁联合生产氧化铬绿、氧化铁红和高纯铬酸盐的方法：中国，107523839B［P］.2019-03- 26. |
| 13 | 冯海涛，董亚萍，李波，等.>利用铬铁制备高纯度铬酸盐的方法：中国，107587155B［P］.2019-06-14. |
| 14 | 冯海涛，李波，董亚萍，等.利用铬铁制备氧化铬绿的方法：中国，107585788B［P］.2019-06-14. |
| 15 | 魏峰，狄蕊，杜锋，等.含铬污泥酸浸出液中铬离子和铁离子的分离［J］.检验检疫学刊，2016，26（4）：14-16. |
| WEI Feng， DI Rui， DU Feng，et al.Study on separation of chromium ion and iron ion in acid extracting solution of chromium sludge［J］.Journal of Inspection and Quarantine，2016，26（4）：14-16. | |
| 16 | 刘佳宁，姜茂发，李昱彤，等.针铁矿法分离铬铁矿硫酸浸出液中Cr3+与Fe3+ ［J］.过程工程学报，2015，15（2）：242-246. |
| LIU Jianing， JIANG Maofa， LI Yutong，et al.Separation of Cr3+ and Fe3+ from sulphuric acid leaching solution of chromite by goethite method［J］.The Chinese Journal of Process Engineering，2015，15（2）：242-246. | |
| 17 | 焦晓斌，段小维，段宏志.锌焙砂浸出过程中两渣分离的探索与实践［J］.中国有色冶金，2016，45（3）：6-9，34. |
| JIAO Xiaobin， DUAN Xiaowei， DUAN Hongzhi.Explorative study and practice on Pb-Ag residue and jarosite residue separation during zinc calcine leaching［J］.China Nonferrous Metallurgy，2016，45（3）：6-9，34. | |
| 18 | 张魁芳，刘志强，曹洪杨，等.用N235从富铁高酸度硫酸浸出液中萃取除铁［J］.中国有色金属学报，2015，25（5）：1370-1377. |
| ZHANG Kuifang， LIU Zhiqiang， CAO Hongyang，et al.Removal of Fe3+ from iron rich and high acidity sulfuric acid leaching liquid by extraction of N235［J］.The Chinese Journal of Nonferrous Metals，2015，25（5）：1370-1377. | |
| 19 | 秦险峰，全学军，叶鹏，等.铬铁矿酸浸过程强化及铬铁分离研究进展［J］.无机盐工业，2020，52（6）：13-19. |
| QIN Xianfeng， QUAN Xuejun， YE Peng，et al.Research progress of process intensification of acid leaching technology from chromite ore and separation of chromium-iron［J］.Inorganic Chemicals Industry，2020，52（6）：13-19. | |
| 20 | 赵青.碱式硫酸铬清洁制备工艺的基础研究［D］.沈阳：东北大学，2015. |
| ZHAO Qing.Fundamental research on the cleaner preparation process of basic chromium sulfate［D］.Shenyang：Northeastern University，2015. | |
| 21 | ZHAO Qing， LIU Chengjun， YANG Dapeng，et al.A cleaner method for preparation of chromium oxide from chromite［J］.Process Safety and Environmental Protection，2017，105：91-100. |
| 22 | 王亲猛.碳素铬铁中元素有效分离及综合利用研究［D］.长沙：中南大学，2011. |
| WANG Qinmeng.Study on effective separation and comprehensive utilization of elements from carbon ferrochromium［D］.Chan-gsha：Central South University，2011. |
/
| 〈 |
|
〉 |