无机盐工业
主管:中海油天津化工研究设计院有限公司
主办:中海油天津化工研究设计院有限公司
   中海油炼油化工科学研究院(北京)有限公司
   中国化工学会无机酸碱盐专业委员会
ISSN 1006-4990 CN 12-1069/TQ
工业技术

碱洗氧化工艺中杂质对硫酸钠结晶粒度的影响

  • 刘壮 ,
  • 安继民 ,
  • 李永军 ,
  • 陈星 ,
  • 赵毅刚 ,
  • 翟瑞国
展开
  • 1.中石油长庆油田分公司,陕西靖边 718500
    2.天津市众天科技发展有限公司
刘壮(1988— ),男,工程师,研究方向为硫回收工艺优化与无机盐化工;E-mail: 495465929@qq.com

收稿日期: 2021-07-02

  网络出版日期: 2022-04-18

Effect of impurity in alkaline washing oxidation process on crystal size of sodium sulfate

  • Zhuang LIU ,
  • Jimin AN ,
  • Yongjun LI ,
  • Xing CHEN ,
  • Yigang ZHAO ,
  • Ruiguo ZHAI
Expand
  • 1. PetroChina Changqing Oilfield Company,Jingbian 718500,China
    2. Tianjin Zhongtian Chem.Eng.Co.,Ltd.

Received date: 2021-07-02

  Online published: 2022-04-18

摘要

针对碱洗氧化工艺脱硫废水中硫酸钠的蒸发结晶,设计开发了硫酸钠蒸发结晶放大实验装置,重点研究了废水中碳酸钠、铁离子和亚硫酸钠杂质对硫酸钠蒸发结晶晶体粒度的影响。结果表明:1.0%(质量分数)的碳酸钠对硫酸钠晶体的粒径影响可忽略;铁以沉淀物形式存在时,易引起硫酸钠晶体结块且粒径变小; 铁以溶解形式存在时,对硫酸钠晶体的粒径影响较小;亚硫酸钠的存在易引起硫酸钠晶体的粒径变小,氧化消除溶液中的亚硫酸钠后,结晶得到的硫酸钠晶体粒径变大。工业装置经过改造后,无水Na2SO4产品的平均粒径由106.71 μm提高至129.99 μm。

本文引用格式

刘壮 , 安继民 , 李永军 , 陈星 , 赵毅刚 , 翟瑞国 . 碱洗氧化工艺中杂质对硫酸钠结晶粒度的影响[J]. 无机盐工业, 2022 , 54(4) : 123 -127 . DOI: 10.19964/j.issn.1006-4990.2021-0397

Abstract

Aiming at the evaporative crystallization of sodium sulfate in the desulfurization wastewater from alkaline washing oxidation process,an experimental device was designed and developed to investigate the influence of the impurities on the evaporative crystallization of sodium sulfate,mainly on the particle size of the sodium sulfate crystal,which include sodium carbonate,ferric ion and sodium sulfite in the wastewater.The results showed that 1.0% mass fraction of sodium carbonate in wastewater had no obvious influence on the particle size of sodium sulfate crystal.When iron existed in the form of precipitate,it was easy to cause sodium sulfate crystals to agglomerate and the particle size becomed smaller.When iron was existed in dissolved form,it had little effect on the particle size of sodium sulfate crystal.The existence of sodium sulfite was easy to reduce the particle size of sodium sulfate crystal.After eliminating sodium sulfite in wastewater by H2O2 oxidation,the crystal size of sodium sulfite was increased apparently.After the transformation of the industrial device,the average particle size of the anhydrous Na2SO4 product was increased from 106.71 μm to 129.99 μm.

参考文献

[1] 陆操, 程荫东. 无水硫酸钠生产、消费及对策[J]. 无机盐工业, 1992(3):14-17.
[2] 李淑萍. 大颗粒无水硫酸钠结晶工艺及数学模型研究[D]. 太原:华北工学院, 2001.
[3] 廖恩鑫, 陈丽芳, 张泽亚, 等. 硫酸钠与氯化钾制备硫酸钾实验研究[J]. 无机盐工业, 2020, 52(10):106-109.
[4] 谢明胜, 卫锋, 王爱广. 颗粒状无水硫酸钠的生产[J]. 无机盐工业, 2003, 35(6):30-31.
[5] 刘云琴. 元明粉结块原因及防止方法的探讨[J]. 无机盐工业, 2001, 33(2):28-29.
[6] 唐娜, 白丽荣, 沙作良, 等. 添加剂对硫酸钠晶体粒度的影响[J]. 盐业与化工, 2007, 36(6):1-3.
[7] 黄欣, 陈业钢, 苏楠楠, 等. 高盐废水分质结晶及资源化利用研究进展[J]. 化学工业与工程, 2019, 36(1):10-23.
[8] 裴旭东, 陈卫红, 李朝恒. 煤化工废水中硫酸钠-氯化钠-硝酸钠分离工艺研究[J]. 工业水处理, 2020, 40(1):63-66.
[9] 雷少成, 李玉林. DTNF膜对煤化工HERO高盐废水的分盐实验研究[J]. 无机盐工业, 2020, 52(9):84-87.
[10] BHARMORIA P, GEHLOT P S, GUPTA H, et al. Temperaturedependent solubility transition of Na2SO4 in water and the effect of NaCl therein:solution structures and salt water dynamics[J]. Journal of Physical Chemistry B, 2014, 118(44):12734-12742.
[11] 张峰榛, 张孝果, 杨虎, 等. 硫酸钠废水真空蒸发结晶脱盐性能研究[J]. 天然气化工:C1化学与化工, 2019, 44(3):49-52.
[12] 许莉, 丁成荣. 铁离子杂质对过硫酸钠结晶过程的影响[J]. 精细化工, 2001, 18(9):547-549.
[13] ZENG G, LI H, LUO S, et al. Effects of ultrasonic radiation on induction period and nucleation kinetics of sodium sulfate[J]. Korean Journal of Chemical Engineering, 2014, 31(5):807-811.
[14] SU N, WANG Y, YAN X, et al. Mechanism of influence of organic impurity on crystallization of sodium sulfate[J]. Industrial & Engineering Chemistry Research, 2018, 57(5):1705-1713.
[15] 曾桂生, 李慧, 王贤勇. 无水硫酸钠结晶热力学及介稳区宽度研究[J]. 南昌航空大学学报:自然科学版, 2012, 26(4):66-70.
[16] 丁爱娟. 亚熔盐法粉煤灰提铝清洁工艺硫行为研究[D]. 北京:北京化工大学, 2013.
[17] 侯长军, 霍丹群, 唐晓萍. 结晶添加剂对硫酸钾结晶过程影响研究[J]. 海湖盐与化工, 2002, 31(2):20-24.
[18] 丁绪淮, 谈遒. 工业结晶[M]. 北京: 化学工业出版社, 1985:74-132.
[19] 科尔索夫. 定量化学分析[M]. 南京化工学院分析化学教研组译. 北京: 人民教育出版社, 1981:234-235.
文章导航

/