收稿日期: 2021-05-17
网络出版日期: 2021-12-16
基金资助
中海油能源发展股份有限公司项目,低温烟气脱硝催化剂的工业侧线研究(E-J719TX17)
Study on new preparation process and performance of V2O5 /（TiO2-SiO2） denitrification catalyst
Received date: 2021-05-17
Online published: 2021-12-16
将偏钒酸铵和羟丙基甲基纤维素搅拌混溶制备滴胶液,以自制的7孔圆柱蜂窝钛硅复合氧化物为载体,采用滴胶涂覆法制备了V2O5/（TiO2-SiO2）脱硝催化剂。通过X射线衍射（XRD）、程序升温还原（H2-TPR）、比表面积分析（BET）和催化剂评价等方法对制备的脱硝催化剂进行分析表征。考察了五氧化二钒在钛硅复合氧化物载体上的分布、五氧化二钒涂覆量等对催化剂性能的影响,并就反应温度、反应空速、氨与一氧化氮物质的量比等条件对脱硝催化剂活性的影响进行了研究。实验结果表明,使用五氧化二钒涂覆量为1.2%（质量分数）的V2O5/（TiO2-SiO2）脱硝催化剂,在反应温度为320 ℃、空速为10 000 h-1、氨与一氧化氮物质的量比为1.2条件下进行脱硝活性实验,一氧化氮转化率达到93.0%。经与工业脱硝催化剂对比实验表明,制备的V2O5/（TiO2-SiO2）脱硝催化剂性能优良,并且降低了钒的使用量,节约了生产成本,减少了环境污染。
孙春晖 , 陈永生 , 刘伟 , 许岩 , 张景成 , 于瑞香 . V2O5/（TiO2-SiO2）脱硝催化剂新型制备工艺及性能研究[J]. 无机盐工业, 2021 , 53(12) : 146 -149 . DOI: 10.19964/j.issn.1006-4990.2021-0191
The series V2O5/（TiO2-SiO2） SCR catalysts were prepared by dripping-glue-coating process that dripped the col-loidal solution into the parallel 7-channel of the self-made honeycomb support.The solution was formed by mixing ammonium vanadate（NH4VO3） and HPMC with high-speed stirring.The prepared denitrification catalyst was characterized by XRD、BET、H2-TPR and catalyst evaluation experiment.The influence of the distribution of V2O5 on support and V2O5 content on the SCR catalyst performance were investigated.The activity of denitration catalyst was also studied in several aspects: reaction temper-ature,reaction space velocity,n（NH3）/n（NO） molar ratio,etc.The results showed the content of the V2O5 of 1.2%,the space velocity of 10 000 h-1,the NH3/NO molar ratio of 1.2,the temperature of 320 ℃,the de-NOx efficiency of the catalyst was as high as 93.0%.Compared with the industrial SCR catalyst,the V2O5/（TiO2-SiO2） SCR catalyst has higher activity,lower con-sumption of vanadium,lower production cost,and less environmental pollution.
Key words： denitration catalyst; vanadium pentoxide; titanium dioxide
| [1] | 杜超. SCR脱硝催化剂发展现状与前景分析[J]. 中国石油和化工标准与质量, 2019, 39(22):119-120. |
| [2] | GB 13223—2011 火电厂大气污染物排放标准[S]. |
| [3] | 赵春林, 梁海龙, 陈鑫, 等. 整体式V2O5-MoO3-CeOx /TiO2 /堇青石SCR脱硝催化剂的制备[J]. 稀有金属材料与工程, 2018(S1):222-225. |
| [4] | 赵世强. 氨气还原氮化五氧化二钒制备V(N,O)粉体与机理研究[J]. 有色金属科学与工程, 2019, 10(5):28-34. |
| [5] | 尹元根. 多相催化剂的研究方法[M]. 北京: 化学工业出版社, 1988. |
| [6] | 马宗青, 扈伟强, 董智, 等. 一种氧化钇掺杂钨复合粉末的旋转式煅烧和还原方法:中国, 109894626A[P]. 2019-06-18. |
| [7] | BOSCH H, KIP B J, OMMEN J G, et al. Factors influencing the tem- perature-programmed reduction profiles of vanadium pentoxide[J]. Journal of the Chemical Society,Faraday Transactions 1:Physical Chemistry in Condensed Phases, 1984, 80:2479-2488. |
| [8] | 刘铭, 梁材, 梁文茂, 等. 含氧量和面速度变化对SCR脱硝催化剂性能影响的研究[J]. 中国环保产业, 2020(4):46-49. |
| [9] | DAHL J K, BUECHLER K J, FINLEY R, et al. Rapid solar-thermal dissociation of natural gas in an aerosol flow reactor[J]. Energy, 2004, 29(5/6):715-725. |
| [10] | LONG R Q, YANG R T. Selective catalytic reduction of NO with ammonia over V2O5 doped TiO2 pillared clay catalysts[J]. Applied Catalysis B:Environmental, 2000, 24:13-21. |
| [11] | 孙辉. V2O5-WO3/TiO2催化剂表面元素价态与脱硝活性及机制的关系[D]. 哈尔滨:哈尔滨工程大学, 2017. |
| [12] | 许波连, 范以宁, 刘浏, 等. V2O5/TiO2催化剂表面钒氧物种的分散状态和催化性能[J]. 中国科学:B辑, 2002, 32(3):235-242. |
| [13] | BUSCA G, LIETTI L, RAMIS G, et al. Chemical and mechanistic aspects of the selective catalytic reduction of NOx by ammonia over oxide catalysts:A review[J]. Applied Catalysis B:Environment, 1998, 18:1-36. |
| [14] | FORZATTI P. Present status and perspectives in de-NOx SCR ca- talysis[J]. Applied Catalysis A:General, 2001, 222(1/2):221-236. |
| [15] | 李亚倩, 李建军, 李海娇. 低温NH3-SCR脱硝催化剂研究现状及进展[J]. 四川化工, 2018, 21(2):13-15,19. |
/
| 〈 |
|
〉 |
