无机盐工业
主管:中海油天津化工研究设计院有限公司
主办:中海油天津化工研究设计院有限公司
   中海油炼油化工科学研究院(北京)有限公司
   中国化工学会无机酸碱盐专业委员会
ISSN 1006-4990 CN 12-1069/TQ
环境·健康·安全

沉钒废水除硅制备冶金级氢氧化铬研究

  • 滕晓慧 ,
  • 孙丽月 ,
  • 庄立军
展开
  • 中信锦州金属股份有限公司,辽宁锦州 121005
滕晓慧(1980— ),女,高级工程师,从事锆、铬、钒等冶金、化工研究与技术工作;E-mail: tengxiaohui2008@163.com

收稿日期: 2020-03-15

  网络出版日期: 2020-09-27

Study on preparation of metallurgical grade chromium hydroxide by removing silicon from vanadium wastewater

  • Xiaohui Teng ,
  • Liyue Sun ,
  • Lijun Zhuang
Expand
  • CITIC Jinzhou Metal Co.,Ltd.,Jinzhou 121005,China

Received date: 2020-03-15

  Online published: 2020-09-27

摘要

研究了以石灰为脱硅剂,采用石灰+片碱(氢氧化钠)沉淀法脱除沉钒废水中的硅,以除硅液为原料制备冶金级氢氧化铬。结果表明,先用石灰调节pH为7.5~8.0,再用片碱调节pH为9.5以上,除硅温度为55~65 ℃,除硅时间为20~30 min,在此条件下除硅率达到67.9%。沉钒废水用石灰除硅后制备的氢氧化铬硅含量低,以二氧化硅质量分数计达到4.2%,可用于冶炼焊剂用、铝剂用金属铬的原料。

本文引用格式

滕晓慧 , 孙丽月 , 庄立军 . 沉钒废水除硅制备冶金级氢氧化铬研究[J]. 无机盐工业, 2020 , 52(9) : 88 -90 . DOI: 10.11962/1006-4990.2019-0519

Abstract

Using lime powder as the desiliconizing agent,and the metallurgical grade chromium hydroxide was prepared from vanadium precipitation wastewater by lime powder+sodium hydroxide precipitation method.The results showed that the sili-con removal rate reached 67.9% under the conditions of first adjusting the pH at 7.5~8.0 with lime powder,then adjusting the pH above 9.5 with sodium hydroxide,the silicon removal temperature of 55~65 ℃ and the silicon removal time of 20~30 min. The prepared chromium hydroxide had a silicon content(calculated as SiO2 mass fraction) of 4.2% and a low silicon content by removing silicon with lime powder.Low-silicon chromium hydroxide can be used as chromium metal smelting raw materials for welding flux and aluminum.

参考文献

[1] 黄道鑫. 提钒炼钢[M]. 北京: 冶金工业出版社, 2000.
[2] 庄立军, 王良, 赵华, 等. 用钒铁冶炼贫渣处理还原沉钒后的废水[J]. 钢铁钒钛, 2014,35(1):64-68.
[3] 滕晓慧, 庄立军, 李文慧. 低COD处理沉钒废水回收低铁含铬渣冶炼金属铬[J]. 钢铁钒钛, 2016,37(2):73-77.
[4] 庄立军, 杨锦铭, 孙丽月. 沉钒上层液用硫酸铝除硅制备低硅氢氧化铬研究[J]. 无机盐工业, 2018,50(12):51-53.
[5] 李国良. 钠化钒渣浸出液的除硅净化[J]. 成都科技大学学报, 1986(4):33-38.
文章导航

/