无机盐工业
主管:中海油天津化工研究设计院有限公司
主办:中海油天津化工研究设计院有限公司
   中海油炼油化工科学研究院(北京)有限公司
   中国化工学会无机酸碱盐专业委员会
ISSN 1006-4990 CN 12-1069/TQ
环境·健康·安全

利用钛白废酸制备硫氧镁水泥的方法研究

  • 任子位 ,
  • 向梅 ,
  • 张坤鹏 ,
  • 刘宏 ,
  • 郭金发 ,
  • 王彤
展开
  • 1. 成都理工大学,四川成都 610059
    2. 重庆两江源环境影响评价有限公司
任子位(1995— )男,硕士研究生,助理工程师,研究方向为新型环保建筑材料、环境工程、地球化学、资源综合利用等;E-mail: 1354570160@qq.com。

收稿日期: 2019-03-18

  网络出版日期: 2020-06-10

Study on preparation of magnesium oxysulfate cement by using titanium white waste acid

  • Ziwei Ren ,
  • Mei Xiang ,
  • Kunpeng Zhang ,
  • Hong Liu ,
  • Jinfa Guo ,
  • Tong Wang
Expand
  • 1. Chengdu University of Technology,Chengdu 610059,China
    2. Chongqing Liangjiangyuan Environmental Impact Assessment Co.,Ltd.

Received date: 2019-03-18

  Online published: 2020-06-10

摘要

钛白废酸是一种液体废物,处理不当将严重污染环境。利用钛白废酸代替硫酸制备硫氧镁水泥,既能保护环境,又可以节省成本。通过钛白废酸与氧化镁反应生成硫酸镁,再添加轻烧氧化镁和改性剂柠檬酸,即可以制成硫氧镁水泥。测试了硫氧镁水泥的凝结时间、抗压能力、微观结构和物相组成。与传统硫酸法制备的硫氧镁水泥相比,采用钛白废酸制备的硫氧镁水泥凝结时间更短,同时在抗压强度、微观结构和物相组成方面两者基本一致,证明利用钛白废酸制备硫氧镁水泥是可行的。

本文引用格式

任子位 , 向梅 , 张坤鹏 , 刘宏 , 郭金发 , 王彤 . 利用钛白废酸制备硫氧镁水泥的方法研究[J]. 无机盐工业, 2019 , 51(9) : 85 -87 . DOI: 10.11962/1006-4990.2018-0575

Abstract

Titanium white waste acid is a kind of liquid waste that will seriously pollute the environment if handled improperly.Using titanium white waste acid to replace sulfuric acid when prepare magnesium oxysulfate cement can not only protect the environment but also save costs.The magnesium oxysulfate cement can be produced by reacting titanium white waste acid with magnesium oxide to form magnesium sulfate,and then adding light calcined magnesia and modifier citric acid.The setting time,compressive capacity,microstructure and phase composition of the magnesium oxysulfide cement were tested. Compared with the magnesium oxysulfate cement prepared by the traditional sulphuric acid method,the magnesium oxysulfate cement prepared by using the titanium white waste acid has a shorter setting time,and the compressive strength,microstructure and phase composition of the two methods were both consistent.It is feasible to prepare magnesium oxysulfide ce ment from titanium white waste acid.

参考文献

[1] 徐长伟, 姜威 . 改性剂对硫氧镁水泥性能的影响[J].混凝土, 2017(10):112-114.
[2] 吴成友, 余红发, 文静 , 等. 改性硫氧镁水泥物相组成及性能研究[J].新型建筑材料, 2013(5):68-72.
[3] 许园园, 徐迅, 卢忠远 , 等. 固硫灰对硫氧镁水泥性能的影响研究[J].新型建筑材料, 2016(9):14-17.
[4] 姜黎黎, 刘江武, 董文俊 , 等. 柠檬酸掺量对硫氧镁水泥耐水性的影响[J]. 硅酸盐通报, 2016,35(12):4093-4096.
[5] 姜黎黎, 陈逸敏, 许可 , 等. 粉煤灰对硫氧镁水泥抗压强度的影响[J]. 硅酸盐通报, 2015,34(5):1427-1430.
[6] 马建华, 王宝仁, 王秀艳 . 用纯橄岩制备硫酸镁的工艺研究[J]. 无机盐工业, 2009,41(11):31-33.
[7] 张贇, 钮德明, 陈长远 , 等. 钛白废酸循环利用工艺的研究[J]. 工业水处理, 2016,36(6):103-105.
[8] 吕利平, 曾行艳, 李航 , 等. 钛白废酸活化制备污泥活性炭及其在榨菜废水处理中的应用[J]. 现代化工, 2018,38(5):99-103.
[9] 王伟, 唐明林, 桑世华 . 钛精矿生产钛白粉废酸的回收技术研究[J]. 现代盐化工, 2017,44(5):50-51.
[10] 谢宇奇, 欧阳辉祥, 胡波启 , 等. 钛白废酸-软锰矿-硫铁矿制备高纯硫酸锰[J]. 无机盐工业, 2013,45(7):49-51.
[11] 吴健春, 路瑞芳 . 钛白副产废酸和七水硫酸亚铁制备一水硫酸亚铁的研究[J]. 无机盐工业, 2018,50(6):76-77.
文章导航

/