无机盐工业
主管:中海油天津化工研究设计院有限公司
主办:中海油天津化工研究设计院有限公司
   中海油炼油化工科学研究院(北京)有限公司
   中国化工学会无机酸碱盐专业委员会
ISSN 1006-4990 CN 12-1069/TQ
环境·健康·安全

含锶废渣制备氯化锶新工艺研究

  • 李常娥 ,
  • 李国庭
展开
  • 1. 河北百润环境检测技术有限公司,河北石家庄 050200
    2. 河北科技大学化学与制药工程学院
李常娥(1983— ),女,硕士,工程师,从事环境检测,环境治理技术开发,特别是水、气、土、固废的检测方法研究;E-mail:1308808636@qq.com。

收稿日期: 2019-08-02

  网络出版日期: 2020-02-26

Study on new technology of preparing strontium chloride from strontium-containing waste residue

  • Chang′e Li ,
  • Guoting Li
Expand
  • 1. Hebei Bairun Environmental Testing Technology Co.,Ltd.,Shijiazhuang 050200,China
    2. College of Chemical and Pharmaceutical Engineering,Hebei University of Science and Technology

Received date: 2019-08-02

  Online published: 2020-02-26

摘要

目前,生产碳酸锶等锶盐的工厂产生的废渣中锶质量分数高达10%,且未被利用,既污染环境,又造成资源浪费。以这些含锶废渣为原料,开发经济价值较高的氯化锶产品。通过实验确定了工艺路线,并考察了反应时间及反应温度对浸取率的影响。通过单因素实验确定了最佳工艺条件:反应时间为4 h,反应温度为80 ℃。进行了氯化锶溶液中脱除杂质的方法研究,解决了从较高浓度锶离子中分离镁、钙这一问题。最终实验样品经分析测试达到了相关产品质量要求。

关键词: 锶渣; 盐酸; 氯化锶

本文引用格式

李常娥 , 李国庭 . 含锶废渣制备氯化锶新工艺研究[J]. 无机盐工业, 2020 , 52(1) : 79 -81 . DOI: 10.11962/1006-4990.2019-0105

Abstract

At present,the waste residue produced by factories producing strontium carbonate and other strontium salts contains up to 10%(mass fraction) strontium,which is not used and causes both environmental pollution and resource waste.With these strontium waste as raw material,high economic value of strontium chloride products was developed.The process route was determined through experiments,and the effects of the extraction time and the extraction temperature on the extraction rate were investigated respectively.The optimum technological conditions were determined by single factor experiment as follows:the leaching time was 4 h and the leaching temperature was 80 ℃.The method of removing impurities in the strontium chloride solution was studied,and the problem of separating magnesium and calcium from a large amount of strontium was solved.The final test samples reached the quality requirements of the products.

参考文献

[1] 徐龙君, 曲歌, 赵庆 , 等. 锶尾矿和废渣的污染现状及资源化利用进展[J]. 资源环境与工程, 2008,22(2):222-224,242.
[2] 曲歌 . 锶尾矿对环境的影响及回收锶盐研究[D]. 重庆:重庆大学, 2008.
[3] 李波, 段东平, 王树轩 , 等. 以碳酸锶废渣为原料制备高纯氯化锶[J]. 盐湖研究, 2013,21(2):58-61.
[4] 金建华, 杨占寿, 东军山 , 等. 响应面分析法优化碳酸锶废渣酸浸取工艺的研究[J]. 无机盐工业, 2017,49(5):52-55.
[5] 金建华, 杨占寿, 李傲 , 等. 锶废渣制备锶盐酸浸取工艺关键参数的实验研究[J]. 无机盐工业, 2016,48(8):60-62.
[6] 天津化工研究院. 无机盐工业手册[M].2版. 北京: 化学工业出版社, 1996: 610.
文章导航

/